 |
This article does not cite any references or sources. Please help improve this article by adding citations to reliable sources. Unsourced material may be challenged and removed. (March 2009) |
 A Metra F40PH |
|
| Power type | Diesel-electric |
|---|---|
| Builder | GM Electro-Motive Division (EMD) General Motors Diesel (GMD) |
| Build date | 1976 – 1991 |
| UIC classification | Bo'Bo' |
| AAR wheel arr. | B-B |
| Gauge | 4 ft 81⁄2 in (1,435 mm) |
| Prime mover | EMD 645E3 |
| Cylinders | V16 |
| Top speed | 103 mph (166 km/h) |
| Power output | 3,000 hp (2.2 MW) |
| Locomotive brakes | Straight air |
| Train brakes | 26-L air |
| Nicknames | "screamer" "screaming thunderbox" |
| WikiProject Trains {{Infobox Locomotive Auto}} |
|
The General Motors Electro-Motive Division model F40PH is a 4-axle 3000 horsepower (2.2 MW) B-B diesel-electric locomotive intended for passenger service, built from 1976 onwards.
Contents |
History
Introduction of the F40PH series was spurred as a replacement for the EMD SDP40F type, Amtrak's first series of locomotives built new for them (since its inception in 1971). Problems with the SDP40F led to the introduction of the F40PH, based on the proven EMD GP40 series freight locomotives using a two axle truck of known reliability. (The term "F40" by itself can lead to confusion, because the first locomotive to bear that designation was the F40C, a passenger C-C locomotive derived from the SD40-2, ostensibly similar to the SDP40F but with an HEP generator.)
The F40PH was also purchased by many commuter railroads, such as Metra, MBTA, Tri-Rail, CalTrain, Metrolink, NJ Transit and GO Transit; all except GO Transit still operate these locomotives.
Dozens of F40PH units remain in service on various railroads, including some bought used from Amtrak by freight lines, such as CSX, for use on business trains. Tourist lines, like Grand Canyon Railway and the Ski Train took them due to their discount price and good hauling capability. A handful were bought by shortline railways.
Equipment
The F40PH is equipped with a turbocharged EMD 645E3 V16 cylinder, two-stroke, water-cooled diesel engine (prime mover) that develops 3,000 tractive horsepower (2.2 MW) at maximum rpm. Due to the high-pitch generated from its EMD 645E3 prime movers, the units have often been nicknamed by railfans and crews alike as "screamers". The main (traction) generator converts mechanical energy from the prime mover into electricity that is distributed through a high voltage cabinet to the traction motors. Each of the four traction motors are directly geared to a pair of driving wheels. The gear ratio of the traction motors to wheel axle determines the maximum operating speed of the locomotive; a standard F40PH has a gear ratio of 57:20 which provides a top speed of 103 mph (166 km/h).
The F40PH has a fully enclosed carbody which provides a cleaner, somewhat more streamlined appearance, than those of conventional hood unit type construction. While enroute, all-weather access to components is possible, passage through the engine room (and to trailing units) normally is used only during maintenance at repair points.
To support passenger service, the F40PH is equipped with a secondary electrical generator known as the head end generator. The HEP unit generates three-phase AC power at 480 v AC 750 A or about 500 kW to provide power to the cars for lighting, heating, and air conditioning. Because head end power must be delivered to the rest of the trainset at a constant frequency, the prime mover in these locomotives must turn at a constant high speed (900 rpm) while delivering head end power (even if the locomotive is standing still). Power to the traction motors is controlled by varying the field excitation of the main (traction) generator.
Later versions of the F40PH have a second small diesel engine at the rear of the locomotive driving the head end power generator. In these versions the prime mover can vary its speed depending on the amount of tractive effort needed. These locomotives can be identified by a small secondary diesel exhaust at the rear end of the locomotive, in addition to their quiet idle. The MPI version of the F40PH was built by Morrison-Knudsen.
Cabbage Car Conversions
In later years, as Amtrak's F40PH fleet was being replaced by the newer GE Genesis-series locomotives, Amtrak converted a number of the retired units—generally ones with major mechanical problems limiting their value in the resale or lease marketplace[citation needed]—into "Non-Power Control Unit" cab cars. Commonly known as "Cabbages," a portmanteau of "cab" and "baggage," these units had their prime movers and traction motors removed, and a large roll-up door installed in the side, allowing the former engine compartment to be used for baggage. The units were renumbered into Amtrak's car-series numbers by adding "90" before the former locomotive number; thus, the original F40PH, number 200, became NPCU number 90200.
Extant former Amtrak examples
There are currently a few ex-Amtrak locomotives that are in railroad museums, private owners and various commuter agencies; some of them are:
- AMTK 231, owned by Chris Fussell/Friends of SP 4449 in Portland, OR.
- AMTK 237, Undergoing rebuild for revenue service on the Grand Canyon Railway (GCRX 237).
- AMTK 239, In Daily Service on the Grand Canyon Railway (GCRX 239).
- AMTK 281, California State Railroad Museum in Sacramento, CA.
- AMTK 295, In Daily Service on the Grand Canyon Railway (GCRX 295).
- AMTK 307, under restoration at the NCTM in Spencer, NC.
- AMTK 411, Agence métropolitaine de transport (AMT) 411, ex GO Transit 511
- AMTK 400, Agence métropolitaine de transport (AMT) 400
- AMTK 319, Agence métropolitaine de transport (AMT) 319
- AMTK 243, Agence métropolitaine de transport (AMT) 243
- AMTK 270, Agence métropolitaine de transport (AMT) 270
- AMTK 287, Agence métropolitaine de transport (AMT) 287
- AMTK 372, Agence métropolitaine de transport (AMT) 372
- AMTK 265, Maine Eastern Railroad 265
- AMTK 291, Maine Eastern Railroad 291
- AMTK 256, Metrolink LA
- AMTK 338, Metrolink LA
- AMTK 396, Metrolink LA / SCAX 800
- AMTK 399, Nashville Music City Star / MCS 122
- AMTK 398, Nashville Music City Star / MCS 121
- AMTK 332, Nashville Music City Star / MCS 120
- AMTK 390, CSXT 9992
- AMTK 395, CSXT 9993
- AMTK 280, CSXT 9998
- AMTK 288, CSXT 9999
- AMTK 363, Tri-Rail 810 (underwent conversion to add separate HEP generator)
- AMTK 379, Tri-Rail 811 (underwent conversion to add separate HEP generator)
- AMTK 365, VRE V33
- AMTK 283, Denver Ski Train, SKTX 283
- AMTK 242, Denver Ski Train, SKTX 242
- AMTK 308, MNCR 4193 (converted to F40PH-2CAT)
- AMTK 310, MNCR 4194 (converted to F40PH-2CAT)
Variants
- EMD F40PH
- EMD F40PHR
- EMD F40PH-2
- EMD F40PH-2C
- EMD F40PH-2CAT
- EMD F40PHM-2
- M-K F40PHL-2
- M-K F40PHM-2C
- MPI F40PH-2C
- MPI F40PH-3C
Gallery
 COASTER F40PHM-2C #2103 at Encinitas, California. |
 An M-K built F40PH-2C #1056, operated by MBTA Commuter Rail, enters the Ruggles station in Boston, Massachusetts. |
 Amtrak F40PH #288 pushes the Downeaster southbound through Scarborough, Maine. The lead unit is a F40PH cab-baggage unit. |
 VIA Corridor Train 73 arriving into Windsor, Ontario, August 5, 2007. |
 A non-powered control unit (NPCU "cabbage") converted from a retired F40PH. |
 Tri-rail F40PH-2C #807 stopped in the West Palm Beach station. |
 Altamont Commuter Express MPI F40PH-2C #3105 at Pleasanton |
 New Jersey Transit F40PH-2 #4125 at Summit, NJ |
References
See also
External links
|
||||||||||||||||||||
|
|||||||||||
This entry is from Wikipedia, the leading user-contributed encyclopedia. It may not have been reviewed by professional editors (see full disclaimer)
