0
2.2L OHV Engines * Drain coolant (about 1 gallon) from the radiator until its below the thermostat housing * Disconnect the radiator hose from the thermostat cover * Remove the bolts and lift the cover off you mat have to tap the cover with a soft-face hammer to loosen it * Not how its installed then remove the thermostat 2.3L and 2.4L OHC Engines * Drain the coolant from the radiator * Remove the exhaust manifold heat shield * Remove the cover that protects the outlet pipe on the thermostat housing by accessing cover bolts through the exhaust manifold runners * Raise and secure the car on jackstands * Disconnect the radiator hose from the metal outlet pipe * Remove the outlet pipe bolt and carefully separate the outlet pipe from the thermostat housing and the engine block * Note how its installed then remove the thermostat from the outlet pipe
Wiki User
∙ 14y ago
Add your answer:
Earn +20 pts
How do you know when thermostat is bad in 1997 Pontiac sunfire?
how do you know when thermostat is bad in 19997 Pontiac sunfire
How do you Change the thermostat in a 1997 suburban?
Where is the thermostat on a 1997 chevy suburban and how do you change it?
Change rear brakes on 1997 Sunfire?
I need help on fixing my back brakes on my 1997 sunfire
What are the signs of a Thermostat going bad on a 1997 Pontiac Sunfire?
less heat in your car
Where is the thermostat on a 1997 KIA Sportage?
how do u change thermostat in a 1997 kia sportage
How do you change thermostat in a 1999 Ford Contour?
how do you change a thermostat for a 1997 Ford Contour
What is the correct way to insert a thermostat on a 1997 Pontiac sunfire 2.2?
Remove the thermostat housing screws and separate the housing, exsposing the thermostat and coolant, remove old thermostat and gasket. Reinstall new thermostat, gasket and coolant.
How to change a distibutor cap on sunfire 1997?
There is no distributor cap on a Pontiac sunfire, only a coil pack. coil pack is located on the back of the engine.
How do you change or replace the thermostat on a 1997 Ford Ranger?
Remove the 2 bolts at the thermostat housing. The upper hose goes to the thermostat housing.
Where is the thermometer on a 1996 Pontiac Sunfire?
thermostat? engine size?
Where is the thermostat located on a 1998 Pontiac Sunfire?
check this site------>
Where is the thermostat on a 1998 Pontiac Sunfire?
Off the water pump
