| Mercury | |
|---|---|
 |
|
| Preserved Bristol Mercury | |
| Type | Piston aircraft engine |
| Manufacturer | Bristol Aeroplane Company |
| First run | 1925 |
| Major applications | Bristol Blenheim Gloster Gladiator |
| Number built | 20,700 |
| Developed from | Bristol Jupiter |
- For the 1917 14-cylinder radial engine see Cosmos Mercury
The Bristol Mercury is a nine-cylinder air-cooled single-row piston radial engine. The Mercury was used mainly on British military aircraft in the 1930s and 1940s. A number were also built in Europe under licence.
At least one Bristol Mercury remains airworthy in 2009.
Contents |
Design and development
The Mercury was developed by the Bristol Aeroplane Company in 1925 as their Bristol Jupiter was reaching the end of its lifespan. Although the Mercury initially failed to attract much interest, the Air Ministry eventually funded three prototypes and it became another winner for the designer Roy Fedden.
With the widespread introduction of superchargers to the aviation industry in order to improve altitude performance, Fedden felt it was reasonable to use a small amount of boost at all times in order to improve performance of an otherwise smaller engine. Instead of designing an entirely new block, the existing Jupiter parts were re-used with the stroke reduced by one inch (25 mm). The now-smaller capacity engine was then boosted back to Jupiter power levels, while running at higher rpm and thus requiring a reduction gear for the propeller. The same techniques were applied to the original Jupiter-sized engine to produce the Pegasus.
The Mercury's smaller size was aimed at fighter use, and it powered the Gloster Gauntlet and its successor, the Gloster Gladiator. It was intended that the larger Pegasus would be for bombers, but as the power ratings of both engines rose the Mercury found itself being used in almost all roles. Perhaps its most famous use was in a twin-engine light bomber, the Bristol Blenheim.
In 1938 Roy Fedden pressed the Air Ministry to import supplies of 100 octane aviation spirit from the USA. This new fuel would allow aero engines to run at higher compression ratios and supercharger boost pressure than the existing 87 octane fuel thus increasing the available power. The Mercury XV was one of the first British aero engines to be type-tested and cleared to use the 100 octane fuel in 1939. This engine was capable of running with a boost pressure of +9 lbs/sq.in and was first used in the Blenheim Mk IV.[1] The Mercury was also the first British aero engine to be approved for use with variable pitch propellers. The Bristol company and its shadow factories produced 20,700 examples of the engine.[2]
Outside the United Kingdom, Mercury was licence-built in Poland and used in their PZL P.11 fighters. It was also built by NOHAB in Sweden and used in the Swedish Gloster Gladiator fighters and in the Saab 17 dive-bomber. In Italy, it was built by Alfa Romeo as the Mercurius. In Czechoslovakia it was built by Walter Engines,
Variants
Note:[3]
- Mercury I
- (1926) 808 hp, direct drive. Schneider Trophy racing engine.[4]
- Mercury II
- (1928) 420 hp, compression ratio 5.3:1.
- Mercury IIA
- (1928) 440 hp
- Mercury III
- (1929) 485 hp, compression ratio 4.8:1, 0.5:1 reduction gear.
_Mercury.jpg)
- Mercury IIIA
- Minor modification of Mercury III.
- Mercury IV
- (1929) 485 hp, 0.656:1 reduction gear.
- Mercury IVA
- (1931) 510 hp.
- Mercury IVS.2
- (1932) 510 hp.
- Mercury (Short stroke)
- Unsuccessful experimental short stroke (5.0 in) version, 390 hp.
- Mercury V
- 546 hp (became the Pegasus IS.2)
- Mercury VIS
- (1933) 605 hp, see specifications section.
- Mercury VISP
- (1931) 605 hp, 'P' for Persia.
- Mercury VIS.2
- (1933) 605 hp.
- Mercury VIA
- (1928) 575 hp (became the Pegasus IU.2)
- Mercury VIIA
- 560 hp (became the Pegasus IM.2)
- Mercury VIII
- (1935) 825 hp, compression ratio 6.25:1, lightened engine.
- Mercury VIIIA
- Mercury VIII fitted with gun synchronisation gear for the Gloster Gladiator
- Mercury VIIIA
- 535 hp, second use of VIIIA designation, (became the Pegasus IU.2P)
- Mercury IX
- (1935) 825 hp, lightened engine.
- Mercury X
- (1937) 820 hp.
- Mercury XI
- (1937) 820 hp.
- Mercury XII
(1937) 820 hp
- Mercury XV
- (1938) 825 hp, developed from Mercury VIII. Converted to run on 100 Octane fuel (previously 87 Octane).
- Mercury XVI
- 830 hp.
- Mercury XX
- (1940) 810 hp
- Mercury 25
- (1941) 825 hp. Mercury XV with crankshaft modifications.
- Mercury 26
- 825 hp. As Mercury 25 with modified carburettor.
- Mercury 30
- (1941) 810 hp, Mercury XX with crankshaft modifications.
- Mercury 31
- (1945) 810 hp, Mercury 30 with carburettor modifications and fixed pitch propeller for Hamilcar X.
Applications
Note:[5]
Survivors
A Bristol Mercury powered Westland Lysander remains airworthy in 2009 at the Shuttleworth Collection, Old Warden, England and is flown at home air displays throughout the summer months.[6]
Engines on display
A Bristol Mercury VII is on display at the Royal Air Force Museum (London).[7]
Specifications (Mercury VI-S)
Data from Lumsden[8]
General characteristics
- Type: Nine-cylinder, single-row, supercharged, air-cooled radial engine
- Bore: 5.75 in (146 mm)
- Stroke: 6.5 in (165 mm)
- Displacement: 1,520 in³ (24.9 L)
- Length: 47 in (1,194 mm)
- Diameter: 51.5 in (1,307 mm)
- Dry weight: 966 lb (438 kg)
Components
- Valvetrain: Overhead valve, 4 valves per cylinder – 2 intake and 2 sodium-filled exhaust
- Supercharger: Single-speed centrifugal type supercharger
- Fuel system: Claudel-Hobson carburettor
- Fuel type: 87 Octane petrol
- Cooling system: Air-cooled
- Reduction gear: Farman epicyclic gearing, 0.5:1, left hand tractor
Performance
- Power output:
- 612 hp (457 kW) at 2,750 rpm for takeoff
- 636 hp (474 kW) at 2,750 rpm at 15,500 ft (4,730 m)
- Specific power: 0.4 hp/in³ (18.35 kW/L)
- Compression ratio: 6:1
- Specific fuel consumption: 0.49 lb/(hp·h) (300 g/kWh)
- Power-to-weight ratio: 0.63 hp/lb (1.04 kW/kg)
See also
Related development
Comparable engines
Related lists
References
Notes
- ^ Warner 2005, pp. 100, 112, 135.
- ^ Bridgman (Jane's) 1998, p. 270.
- ^ List from Lumsden 2003, pp. 104-108
- ^ Gunston 1989, p.32.
- ^ List from Lumsden, the Mercury may not be the main powerplant for these types
- ^ The Shuttleworth Collection - Westland Lysander Retrieved: 30 July 2009
- ^ RAF Museum - Bristol Mercury Retrieved: 4 August 2009
- ^ Lumsden 2003, p.105.
Bibliography
- Bridgman, L, (ed.) (1998) Jane's fighting aircraft of World War II. Crescent. ISBN 0-517-67964-7
- Gunston, Bill. World Encyclopedia of Aero Engines. Cambridge, England. Patrick Stephens Limited, 1989. ISBN 1-85260-163-9
- Lumsden, Alec. British Piston Engines and their Aircraft. Marlborough, Wiltshire: Airlife Publishing, 2003. ISBN 1-85310-294-6.
- Warner, G. The Bristol Blenheim: A Complete History. London: Crécy Publishing, 2nd edition 2005. ISBN 0-85979-101-7.
Further reading
- Gunston, Bill. Development of Piston Aero Engines. Cambridge, England. Patrick Stephens Limited, 2006. ISBN 0-7509-4478-1
External links
 |
Wikimedia Commons has media related to: Bristol Mercury |
- Recorded sound of the Mercury V S2 engine used in PZL P.11c (mp3 format)
|
|||||||||||
|
|||||
|
||||||||||||||
This entry is from Wikipedia, the leading user-contributed encyclopedia. It may not have been reviewed by professional editors (see full disclaimer)
