Are you shure that is a wiring problem? IFS trucks have a thermal actuator, which engages the front differential. It goes bad in alot of IFS trucks. If your front driveshaft rotates while your in 4wd, but wheels turn like in 2wd. That your problem. Two ways of fixing the problem: 1) get a new 4wd actuator from the auto parts store or 2) log on to 4wheelparts.com find the Posi-Lok system for your truck. If your truck is a non-offroad, just use 4wd in bad weather and gravel/dirt roads number 1 is your best pick. If you offroad, work and/or depend on your 4wd, think about number 2.
chevy parts online
Need one hell of a lot more information then this
"Snug" will work
in a chiltons or hanes manual located at any auto parts store
A fuse diagram for a Chevy K1500 Silverado can be found in a Chilton's Automotive Repair Manual. Chilton makes repair manuals for many different vehicles.
Check your state's electronic library for Chilton library. For MI it's mel.org than mel databases than Chilton Library.
It is important to have a diagram of all the line in a car while owning it. A person can get a diagram of the vacuum lines in a 1996 Chevy Suburban K1500 2WD by purchasing the maintenance or repair manual at an auto part shop.
You can find wiring diagrams for the 1991 Chevrolet K1500 1/2 ton pickup with 4-wheel drive and 5.7-liter 8-cylinder on the AutoZone website. You can also find fluid capacities, torque specs, and repair information and instructions.
If you will lay down under the front of the truck and look up over the skid plate towards the center of the differential but to the right a little you will see a plug that a 3/8 rachett end will fit in. Remove it and put finger into hole if you touch oil then its full if not add gear oil until it runs out.
The egr valve is on the top of the engine in the front it is plugged into your wiring harness and has two bolts holding it on, it is shaped like a cylinder and is next to the water jacket on the engine.
THere is a fill plug located approximately 2\3rd up from bottom. fill differential with Diff oil until level with bottom of the plug.
Aprox 4 and 1/2 pints.
I am trying to hook up a brake controller on my 1998 k1500. I cann't find the brake light wire on the truck under the dash or the hood. I need help!
You can find a 1996 Chevrolet 350 cubic inch motor diagram at most Chevrolet dealerships. Most auto-parts stores will also have the motor diagram.
www.installdr.com all diagrams of cars and color code information
The Detrioit Locker was common on Z-71 4x4 though i cannot say it is on every Z-71.
Have your actuator on the front right axle tube checked
My 93gmc z71 was 13/8 sae
will a 95 chevy k1500 transfer case hook up to a 96 chevy k1500 transmission
If the motor is the same the wiring harness should fit. Only thing I would check is the sending units. As long as both vehicles have gauges or both have warning lights all should be fine.
clockwise 18436572 #1 cyl on pass side, front