First, you will need a t-27 star screwdriver. Remove the screws that hold in the turn signal bezel. Then remove the screws that hold in the headlight assembly. Locate the 3 wire plug that connects to the headlight. Remove this plug. Remove the bulb from the headlight assembly. Do not twist the assembly, because there is a line-up nouch built in to the assembly. Replace the defective bulb, being extremely careful not to touch the bulb with your fingers. The oil on your hands will cause a hot spot and may cause the bulb to explode. Installation is the reverse of removal.
Under the instrument panel on the driver side
The 1996 ford Aerostar has a curb weight of 3,487 lbs. The gvwr of the Aerostar van is 5,300 lbs.
cant turn the key ignition on my 1996 aerostar ford
How do you open sliding door on a 1996 Ford Aerostar Van that will not disengage?
Bank 1 is the passenger side of your engine in a 1996 Ford Aerostar
According to the 1996 Ford Aerostar Owner Guide : ( 21.0 U.S. gallons )
According to the 1996 Ford Aerostar Owner Guide : ( 5W-30 ) is the preferred oil
According to the 1996 Ford Aerostar Owner Guide : ( 21.0 U.S. gallons / 79 litres )
the head lamp has a removable bulb that twists out like a regular house bulb
Apparently it is at the back of the engine(under doghouse). I haven't done mine yet!!
Front seating area, driver side, behind dash, driver side of steering column, mounted above fuse panel.
Same key as ignition...
On a 1996 Ford Aerostar : The fuse box is under the instrument panel , on the drivers side
A ( 1996 ) Ford Aerostar has a ( 21.0 U.S. gallon / 79.5 litre gas tank )
The 1996 Aerostar did not come with a 3.8 V6. It is a 3.0 or 4.0 http://autorepair.about.com/library/firing_orders/bl-ford-firing-96.htm
No , both the 3.0 and 4.0 liter Over Head Valve ( OHV ) engines used in a 1996 Ford Aerostar use ( 1 ) timing CHAIN
95 - 105 Ft. lbs.
On a 1996 Ford Aerostar : I believe if you open the drivers door , on the latch pillar , you will see an information sticker that shows the original size of tires on the vehicle from the factory
According to the ( 1996 ) Ford Aerostar Owner Guide : With engine oil filter change : The 4.0 liter V6 engine takes : ( 5.0 U.S. quarts / 4.7 liters ) * 5W-30 is the PREFERRED oil
1-4-2-5-3-6 1=front passenger side, 4=front driver side, 2=center passenger side, and 5=center driver side for cylinder orientaion
Look at the lower rear end of the engine
.052-.056 ========================================================== The above answer is correct if you have the 4.0L V6 engine in your 1996 Ford Aerostar , but according to one of Fords websites if it is the 3.0L V6 the spark plugs are gapped at ( .044 inch )
Not even close