Thermostats
1995-2005 Chevy Cavaliers

How do you replace the thermostat located on a 1999 Chevy Cavalier?

212223

Top Answer
User Avatar
Wiki User
2008-02-26 21:10:07
2008-02-26 21:10:07

I just did mine. It is located at the front of the engine under the alternater. You will need to open the peacok to drain the radiator fluid. I believe that is located at the lower drivers side of the radiator. Where the thermostat is located will be two bolts, 10mm I believe. remove these two bolts. The two metal pcs will now come apart. Take out the thermostat. Clean the two metal halves where you removed the thermostat from (from dirt and debree). You will need a small round gasket the just goies around the thermostat piece itself. There is no paper gasket needed. Put this small gasket around the thermostat, and I also used some high temp gasket maker also. Putting this just around the rubber gasket the you installed around the thermostat. Now insert the thermostat, level and straight in. Connect the two halves together (lever and straight) and tighten the two bolts. Put in new coolant and ready to go.

12
๐Ÿ™
0
๐Ÿคจ
0
๐Ÿ˜ฎ
0
๐Ÿ˜‚
0

Related Questions

User Avatar

where do i find the thermostat for 99 cavalier

User Avatar

Remove the water supply hose from your 1988 Chevy Cavalier thermostat housing. Remove the thermostat housing bolts. Lift the old thermostat out and drop in the new thermostat.

User Avatar

To replace the thermostat on a 91 Cavalier you need to drain the radiator. Remove the top radiator hose and water inlet. Remove the thermostat from under the inlet. Install the new thermostat and reinstall the inlet and hose. Fill the radiator with fresh antifreeze.

User Avatar

Remove the water supply hose from the top of your 2005 Chevy Cavalier thermostat housing. Remove the thermostat housing retaining bolts. Lift the old thermostat out and drop in the new thermostat.

User Avatar

It will be in the thermostat housing where the radiator house connects to your motor.

User Avatar

If it's an automatic you will have to remove the exhaust manifold because the thermostat is located on the backside of the engine on the driver's side under the exhaust manifold.

User Avatar

how do you change a thermostat sensor in a 2001 Chevy cavalier and where is it

User Avatar

The thermostat on a Chevy 2.2 engine should be located under the top hose inlet. The top hose as well as the inlet need to be removed to get to the thermostat.

User Avatar

The thermostat is located in the thermostat housing at the engine end of the top radiator hose.

User Avatar

i need to find location of fuel filter on 1993 Chevy cavalier

User Avatar

Usually in housing at engine end of upper radiator hose

User Avatar

At the engine end of the upper rad hose, Make sure when you replace it you put the spring toward the enigne. IS THERE A PICTURE TO SHOW WHERE?

User Avatar

the thermostat is located behind the water pump. there are 2 8mm bolts holding it in. unscrew, pull old thermostat out, put new one in and put back together. Simple - 9 I would have given it a 10 but the bottom bolt can be a pin to get to.

User Avatar

I would replace the thermostat. This sounds like the thermostat is stuck open.

User Avatar

Take a look where the lower radiator hose connects to the engine. Where the hose connects, you should find the thermostat.

User Avatar

Where is the thermostat located in a 2004 Chevy SSR

User Avatar

How do you remove and replace wiper switch on 2002 Chevy Cavalier

User Avatar

Where is the stater located on a Chevy Cavalier located?

User Avatar

When viewing the engine from the drivers side fender, the thermostat is located on the right rear of the block. Follow the radiator hose that travels over the transmission and it will lead you right to it.

User Avatar

It is at the engine end of the top radiator hose.The housing is the thermostat housing and the thermostat is located therein.

User Avatar

The thermostat is located under the housing cover bolted on the motor. follow the top radiator hose to the motor. the thermostat is under the hose flange that the radiator hose attaches to.

User Avatar

located in front of rear axecel passanger side


Copyright ยฉ 2020 Multiply Media, LLC. All Rights Reserved. The material on this site can not be reproduced, distributed, transmitted, cached or otherwise used, except with prior written permission of Multiply.