You can find a Stage 2 or 3 clutch on eBay for about the same price as you could buy and OME clutch at your local autoparts store. About 150 for the clutch, and 100 to 300 for installation (depending on the mechenic). -Antwon00
The average price for a fitted replacement clutch is $180. The clutch will require three hours of labor to install.
Should be between 3/4 and 1 inch of freeplay in clutch pedal
i think the clutch pedal should be the same as a 94 escort where it would be around 2.5 inches wide and 2 inches tall
If you do not use the clutch to shift, there are a couple of parts that will eventually wear to the point of causing the transmission to drop out of gear. Given the cost of clutch replacement or gear replacement, you should always use the clutch. Similarly, you should not downshift (with or without the clutch) to slow the vehicle down. Use the brakes. Brake pad replacement is simple and inexpensive on most motorcycles.)
Should be right beside the brake master cylindar.
Whenever you are having a problem with the clutch disengaging the engine from the transmission it is advisable to bleed the clutch slave cylinder. If the clutch can't be operated by bleeding the slave cylinder then the clutch master cylinder is gone and should be replaced.
the fly wheel should have been turned.
Labor should be around $350. You can get the Exedy clutch kit (OEM) off Ebay for $180 shipped.
Parts,$300 and the book time for a 4x4 Rav is 12hrs as the engine/trans have to come out as a unit to replace the clutch.
under the hood you should have the brake master cylinder which is larger and a smaller reservoir and this should be for the clutch.
A variable DC servo will last for some time. Just make sure to properly keep it maintained. Since the motor is a replacement for a clutch motor you should expect your motor to last a very long time. The motor comes with a full year warranty.
It should be beside the engine oil pan, in the bell housing on the driver's side of the car.