answersLogoWhite

0


Best Answer

1.Lower corner on radiator facing engine you will find a plastic drain screw has 2 tabs hold twist counter clockwise to drain radiator ,or lower 3" hose can be removed but will drain very fast ,I use an old deep cat box to drain into . 2.Remove top half of fan scroud 2- top bolts and 2 -mid side bolts. 3.Remove upper radiator hose at raditor fold out of the way,remove lower raditor hose let hang not in the way. 4.Looking at van from front between radiator and fan left side there are 2 metal lines going into radiator these are transmission cooling lines remove with line wrench.I take a baggie and tie tie over end of lines for fluid drain catch. 5.Now look right side same area like trans lines if there are 2 lines this side remove they are oil cooler lines most dont have some do come with tow package." " 6.Now lean radiator twards fan unseat from bottom rubber lift left side 3-4 inches will come out left first. Hope this helps!!!

User Avatar

Wiki User

โˆ™ 2008-04-05 00:11:46
This answer is:
๐Ÿ™
0
๐Ÿคจ
0
๐Ÿ˜ฎ
0
User Avatar
Study guides
๐Ÿ““
See all Study Guides
โœ๏ธ
Create a Study Guide

Add your answer:

Earn +20 pts
Q: How do you replace the radiator step by step on a 1992 Chevy Astro van?
Write your answer...
Submit
Related questions

What is the spark plug gap for a 1992 Chevy astro?

.035" Check other tuning information as listed on the radiator fan shroud.


Max gross weight of 1992 Chevy Astro van?

2000 Chevy Astro Van weight


How do you drain the radiator on a 1992 Chevy Corsica?

The radiator drain on a 1992 Chevy Corsica is located on the bottom, left side of the radiator. It provides a quick and effective way to drain the radiator during maintenance.


How do you replace a CV joint on a 1992 Chevy pickup?

how do you replace a CV joint on a 1992 Chevy pickup?


How do you replace the radiator on a 1992 Honda Accord LX?

How do you replace a radiator on a 1991 Honda Accord


Where is the radiator draincock on a 1992 Chevy Corsica?

It is located on the drivers side of the car on the bottom of the radiator


Where is ECM computer on 1992 Chevy Astro?

behind right kick panel


Where is the radiator located on a 1992 astro van on the top of the engine or bottom?

the location of the radiator is in front of the engine.almost always in front behind the front bumper.


Where can you find a repair manual for a 1992 Chevy Astro Van?

any parts house


What is gross weight of 1992 Chevy Astro van?

a curb weight of 3897 lbs.


Where is the thermostat located on a 1992 Chevy Astro?

Do you have the V6 engine? I think it is directly below where the top radiator hose connects to the engine. Disconnect that radiator hose, and the connection should be on a peice of metal that comes off with two bolts. Take it off and the thermostat is underneath.


Where is the radiator drain plug for a 1992 Chevy Beretta?

it is on the side almost at the bottom of the radiator..very hard to get too !!!!


I need driver side door handle for 1992 Chevy astro?

Check the junk yards


How Do You Replace Ignition In 1992 Cavalier?

how do you replace ignition switch on a 1992 Chevy cavalier 2.2 4 cylinder


Can you replace a 350 with a 305 in a 1992 Chevy?

yes


Do you have to take the radiator out to replace the alternator on 1992 Ford E-150?

No you do not.


How much time on average is to replace the timing chain on a 1992 Chevy Corsica?

It will take an experience mechanic approximately 8 hours to replace the timing belt in your 1992 Chevy Corsica. The 1992 Chevy Corsica does not have each timing chain, it has a timing belt.


What are signs and symptoms of a bad ignition coil on 1992 Chevy astro?

No electrial spark or fire at the plugs.


How do you replace the water pump on a 1992 Chevy Cavalier?

Drain the radiator. Remove the pump belt. Remove the fan and shroud if needed. Unbolt the pump and remove it . Bolt on the new pump. Reinstall the fan and shroud, the belt, then refill the radiator.


What is an estimated cost on having a mechanic replace a intake gasket on a 1992 Chevy astro van?

Depends on your location and labor rates. I would suspect ~400-600 for a private mechanic, more at a dealer.


How do you replace the electric fan on the radiator of a 1992 Chevrolet Cavalier?

Simply remove the 4 bolts holding it on and replace it.


How much weight can a 1992 Chevy Astro van extended 2wd carry?

Its maximum payload is 1983 lbs.


Where can you find a wiring diagram for a 1992 Chevy astro?

All of the different wiring diagrams are in the back of the haynes repair manuals made for astro vans. you can get them at any autozone or advance


How do you replace a radiator in a 1992 Chevy S10 pickup 4-cylinder 5 speed no ac?

Remove fan shroud Drain radiator Remove upper and lower radiator hoses Remove upper mounting bolts Lift radiator out of lower support cradle


Why would a 1992 Chevy astro cs rev irratically in idle?

vacuum leak, bad idle control sensor