Diesel 406 gear box removal is best done with the use of an inspection pit and is as follows: * Strip all obstructions from above the engine, battery, air box, air pipes, starter motor ect. * strip obstructions from underneath * Drain gear box oil- this is a bit smelly and should be about 2ltrs but some models will be 3.5ltrs * raise the front wheels off the ground and support on axle stands * support the gear box and engine sump separately - a bottle jack is ideal * undo the gear box mount from under the battery area * disconnect the drive shaft from the near side * disconnect the speed sensor * disconnect the clutch cable and remove lever * undo the gear box / clutch casing bolts (there is no gasket on refitting) * slide off the gear box and casing Whilst the gear box is off is an ideal time to check clutch wear. Many 406 gear box / clutch housings do not have an inspection window, so great care needs to be taken when refitting a gear box to ensure the clutch is evenly connected. For doing this at home / DIY allow a full day for removal and refitting. Ensure the ignition key is not in the car when the battery is refitted, some systems will activate the central locking, and finally ensure you have the stereo code to hand once all work is complete. The detail above is based on work I carried out in the last few weeks, a Haynes Manual will give a full description of the procedure with pictures.
no
the switch is located on top of the gearbox,under the airfilterbox
how do youremove a starter moto on a peugeot 406 please
To check the automatic gearbox oil on your 2002 Peugeot 406, first ensure the car is on a level surface and the engine is running at idle. Locate the transmission dipstick, usually found near the back of the engine bay. Remove the dipstick, wipe it clean, reinsert it fully, then remove it again to check the oil level; it should be within the marked range. If low, add the recommended type of fluid through the dipstick tube.
Slowly
This is a complex procedure, get a manual for this vehicle.
WHERE THE HOM ON THE peugeot 406 2.0hdi out sade
were will i get information for 1996 peugeot 406 petrol
How do you change the ignition coil on a peugeot 406 coupe?
not an expensive job to do. part cost about £10 but apparently it is an awkard job as a part of the dash on passengers side needs removing to get in at it. how do you remove a heater motor from a peugeot 406 do you have to remove the full dashboard or just the glove compartment
on the side of gearbox at top a remove ns wheel to see it its an 8mm hexagen shaped bolt
where is the gearbox oil fill on peugeot expert hdi 2004