0
- Disconnect the negative battery cable.
2. Remove the serpentine belt and timing belt cover.
3. Loosen the water pump bolts and release tension with tool J-33039 or equivalent.
4 . Raise and support the vehicle safely.
5. Remove the crankshaft pulley.
6. Carefully lower the vehicle, then remove the timing belt To install:
- Turn the crankshaft and the camshaft gears clockwise to align the timing marks on the gears with the timing marks on the rear cover.
- Install the timing belt, making sure the portion between the camshaft gear and crankcase gear is in tension.
- Using tool J-33039 or equivalent, turn the water pump eccentric clockwise until the tensioner contacts the high torque stop. Tighten the water pump screws slightly.
- Turn the engine by the crankshaft gear bolt 720° to fully seat the belt into the gear teeth.
- Turn the water pump eccentric counterclockwise until the hole in the tensioner arm is aligned with the hole in the base.
- Tighten the water pump screws to 18 ft. lbs. (24 Nm), while checking that the tensioner holes remain as adjusted in the prior step.
- Install the crankshaft pulley, timing belt cover and the serpentine drive belt.
Wiki User
∙ 14y ago
Add your answer:
Earn +20 pts
How Do You Replace Ignition In 1992 Cavalier?
how do you replace ignition switch on a 1992 Chevy cavalier 2.2 4 cylinder
How much time on average is to replace the timing chain on a 1992 Chevy Corsica?
It will take an experience mechanic approximately 8 hours to replace the timing belt in your 1992 Chevy Corsica. The 1992 Chevy Corsica does not have each timing chain, it has a timing belt.
How do you replace the lighter on a 1992 Chevy Cavalier?
Go to the auto zone for parts and instructions
How do you remove a backseat from a 1992 Chevy Cavalier?
i would like to remove the backseat from my 1992 chevy cavalier
Where is the fuel pump located on a 1992 Chevy Cavalier?
In the gas tank. Costs about 300-500 dollars for a shop to replace it..
Where is the directional flasher in a 1992 Chevy Cavalier?
The directional flasher for a 1992 Chevy Cavalier is under the dash. It is mounted on the drivers side, beside of the steering column.
How do you replace a CV joint on a 1992 Chevy pickup?
how do you replace a CV joint on a 1992 Chevy pickup?
Do you have a picture of location of crankshaft position sensor for 1992 Chevy Cavalier 2.2L ohv engine?
Do you have a picture of location of crankshaft position sensor for 1992 Chevy Cavalier 2.2L ohv engine?
Will a 1990 or 1992 Chevy cavalier heater core fit in a 1992 grand pr ix?
No it will not
Will a 2.0 liter engine and the transmission from a 1984 Chevy Cavalier fit in a 1992 Chevy Cavalier?
That is referred to as "back dating" and it is illegal at the federal level.
1992 Chevy cavalier where is the fuel pump located?
It is in the fuel tank.
What kind of brake fluid goes in the 1992 Chevy Cavalier?
DOT3
