0
How do you change choke cable on 1998 evo motor 1340cc harley Davidson?
Wiki User
∙ 14y ago
Not really a choke on the CV models. It is, instead, an enrichner valve that adds more fuel at idle until the engine has warmed. If not closed bike will continue to idle at a higher RPM and may foul the plugs.
To change the plastic nut must be loosened and the cable unscrewed from the body. Replace with like . . . all there is to it. You may have to remove the carb on some models to access the fitting. Do not overtighten the plastic fittings upon re-installation. Check the fuel line inlet elbow while you're at it to ensure it is not cracked (common issue). If cracked, grip the elbow in a vise and turn the carb body, thus pulling it out. Tap in a brass replacement ensuring the elbow is at the same angle as the original (mark with paint pen before removing original).
Good luck.
Wiki User
∙ 14y ago
Add your answer:
Earn +20 pts
Is there a speedometer sensor on a 2000 harley Davidson ultra classic?
If you don't have a speedo cable on your front wheel, you have a speedo sensor. I believe that change was made in 2000.
What would cause the negative battery cable on your Harley-Davidson to fry?
Take it to an experinced mechanic and do not pass go!
Where is the fuse box on a 2001 harley Davidson sportser?
the speed cable hung up and no break lightsand turn signals
How to Reset alarm Harley Davidson 1450?
You must disconnect the battery cable for a short time. Don't for get you must double click the the alarm button to turn off alarm, once turned on.
How do you fix a speedometer on a 2005 Harley Davidson s?
Need to figure out exactly what's wrong with it first. Maybe it needs to be replaced, or maybe it's just in need of a new speedometer cable.
How do you adjust the clutch on a 2004 wide glide harley Davidson motorcycle?
To adjust the cable just go 1/2 way down the clutch cable and pull the rubber over the adjuster. loosten the lock nut and adjust the cable so there is about 1/8" free play at the handle.
Can Harley Davidson motorcycle run without idle cable?
Yes it can, but it is not recomended. There is a spring in the carb or throttle body (depends on the year of your bike) that will return the bike to idle. BUT if there is a Kink in the throttle cable or any other control problem, this spring will not be strong enough to slow the engine down. If Harley Davidson did not think the return or idle cable was necessary, they would have saved the money and not installed it. I would only recomend this operation in a emergency situation, such as a breakdown on the road. Keep your bike and yourself safe and make a proper repair. Don's Motorcycle Repair Ride Safe
Where do you add transmission oil on a 2003 Harley Davidson Electra Glide?
You can add transmission fluid, to your 1985 Harley-Davidson, through the transmission fluid. Check opening. A funnel will help to get the fluid in without spilling.
What are the clutch adjustments for 1980 harley Davidson fxs?
You should buy a manual for that information.
1998 Harley Davidson Sportster 1200 won't start even when you have replaced the battery and coil?
Try checking the gorund cable at the opposite end from the battery. I had one come loose on my sporty and it would not start but the lights would come on.
Why would your 87 soft tail harley Davidson motorcycle with a 5 speed transmission keep eating the throw out bearing?
It sounds to me like the clutch adjustment isn't correct. If the cable is too tight, it will cause the bearing to spin continuosly causing it to wear out prematurely.
How do you change throttle cable on harley?
I bought the service manual for my bike. It explained in detail everything I needed to do. If your going to buy the manual buy it online it's usually cheaper.
