un screw the cap from the exhaust tip ( there will probably be three screws, use in Allen wrench to remove them. when you take that of the baffle usually comes out with it cause its connected to the tip. than sart up the quad and it will be wicked loud. i would run it like this for too long tho. it will ruin the engine.
Some stock pipes have a removeable baffle , others dont . If yours can be removed there should be some bolts or screws at the back of muffler . Remove the screw and the baffle should pull out with a little tugging .
yes, just take of the 3 bolts and slide the baffle right out!
Yes. There are 3 screws on the muffler holding it on. Remove those 3 screws and pull the baffle out. Talk a look at the related link for a picture of the baffle. you can see the 3 screws that need to be removed.
yes
of course not . It will just make it louder . I have a 2003 xr 80 r without a baffle , and it is louder and a little faster than the stock xr 80 , and I've been driving it like that for years and still runs as good as stock . So it does bump up your speed a little , but will let it breath better .
Making a motorcycle exhaust louder can be achieved by removing the baffle in the muffler, or shortening the length of the muffler. If applicable you can also change to a high volume end cap. Note that several countries have regulations regarding noise levels from vehicles. Remember to check with your local road vehicle authority to make sure you will not be fined.
take to muffler shop
you have too take a punch and punch around the baffle itself all the way around till the baffle is free standing then take a pair of pliers and pull it out. i did this personally and it worked wonders.
A free flow muffler can improve mileage but by not by much. It would take a long time to recoup the cost of a new muffler.
Doing it yourself? Just the muffler? $50+/- Take it to a muffler shop where they'll replace the exhaust pipe, the tail pipe and the muffler with a "lifetime replacement", and it could get expensive.
Baffle the bear is in K3 (the snow world) when you find him, take the package to Blue. He will give you a bowling ball. take the bowling ball to Bridgegar Bazooka bear and he'll fire it off
take it to a muffler shop