0
the easiest way to check if the stator is gone is by taking a volt meter (dc) hook to the battery it should show at least 12.7 volts fully charged. start bike with meter still hooked volts should go up when you give it throttle. up to about 14.5 max. if meter volts don't change your stator is shot if it jumps to around 18-19 volts your regulator is shot. this is the quick way to check your charging system
To test your stator, unplug the regulator from the socket. With a meter set on AC above 100 volts, insert the probes into the stator socket. Start the bike. When you give the bike throttle you should see AC current about 16 to 20 volts per 1000 RPM. You should see about 32 to 40 volts @ 2000rpm. Anything below that, and your stator is faulty.
To test for a bad regulator, unplug the regulator from the stator.
With a test light, make sure you connect the ground well on the test light and touch each pin on the regulator. If the test light lights at all, your regulator is bad.
If you test from the battery terminals, you are checking the whole system. With the meter switched to DC above 20 volts, apply the positive and negative probes to the positive and negative probes on the battery with the battery cables attached. Have a friend start the bike and slowly apply throttle. At idle you should have at least 13 volts. This output should increase as you rev the bike up to about 14.7 volts. It should never exceed 14.7 volts. If the voltage does not rise with throttle, your regulator or stator could be bad which is why you want to perform the test I listed, as listed. If the voltage rises above 14.7 volts the regulator is definitely At Fault.
The regulators on these bikes are notorious for going bad. The regulator and rectifier circuit are housed in the same unit.
Wiki User
∙ 12y ago
Add your answer:
Earn +20 pts
When was Springer - EP - created?
Springer - EP - was created in 2003-05.
What are the release dates for The Jerry Springer Show - 1991 2003-10-30?
The Jerry Springer Show - 1991 2003-10-30 was released on: USA: 30 October 2003
Can you test stator by removing battery cables?
nope....stator as in the alt? dont do it. this was a test before the computer days... you will surge/ zap the comp. or did you mean starter? either way the answer is no
Hello Suzuki DS80 no spark what could be the problem?
check coils stator and all connections test procedure check coils stator and all connections test procedure
How can you test a stator on a 1983 xr80 dirt bike?
yes for continuity
Why does the battery keep going dead even after buying a new battery and stator for a 1998 Harley Springer?
Is the voltage regulator any good? If it is, you could have a short anywhere on the bike.
Where is an alternator on a 2003 harley Davidson wide glide?
The Alternator which is also called a Stator is located inside the primary case. You will have to remove the primary coverand the primary chain. The Stator is bolted to the engine at the crankshaft.
How do you test a stator?
With a mutimeter test between each lead (usually yellow in color), the reading should be approximately one (1) ohm. or close.
What year did Harley Davidson start to make a heritage springer?
Heritage Springers with the Evo motor were made from 1997 to 1999. From 2000 to 2003, the Heritage Springer was made with the TC88 motor.
What type of motor has a stator?
An electric motor has a stator and a rotor. The stator does not move. The rotor rotates inside the stator.
What are the ratings and certificates for Test Australia The National IQ Test 2003 - 2003 TV?
Test Australia The National IQ Test 2003 - 2003 TV is rated/received certificates of: Australia:G
How to test banshee stator?
With a mutimeter test between each lead (usually yellow in color), the reading should be approximately one (1) ohm. or close.
