0
How long does it take to remove the gearbox Renault espace 2.2 diesel?
Wiki User
∙ 11y ago
Autodata states 8 hours, however you could times this by 5 or even 6 if you have never done it before, dont have a lift or pit and are working on it on the ground.
You need to drop the whole subframe to allow the box to drop this entails removing both ball joints and unbolting the frame and wishbones. You also have to remove the lower engine mount completely,also makes sure you have undone the brakepipe brackets, 2 13mm bolts in both wheel arches to the front of the trackrod ends. From the top you need to remove the battery and its tray and below this is the ecu, you can put this to one side without taking the connectors out and remove the ecu tray. This will allow you to access the top mouting bolt of the gearbox and also the starter motor that's attached to the gearbox. There are also 2 13mm bolts hidden under the starter motor.
When replacing the gearbox make sure you have new transmission oil as you will have to drain the oil before you do anything. It states 75w/80 however transmission oil has progressed so you will find that nearly everyone will recommend a general 75w/90.
All in all its a pig of a job and should only be done if
A) you have some mechanical knowledge
B) Your a fruit loop!
Wiki User
∙ 11y ago
Add your answer:
Earn +20 pts
How do you remove the rear window winder on 2002 Renault espace?
Just pull it!
How do you remove gearbox Renault megane 1.6?
To remove gearbox Renault megane 1.6, one needs to first and foremost remove the gearframe from the system. Then reboot the engine and make sure that the gearframe is replaced.
How do you remove a selector shaft from a Renault laguna gear box?
Because of some french idiots, you have to remove the gearbox. And to remove the gearbox... omg
How do you remove an alternator on a Renault grand espace 2.2dci 2005?
Remove front bumper for full access
How do you remove a manual gearbox on a Renault clio?
Please guide me on were i can check the gearbox oil level on my 2001 manual 16v Renault 1.4 clio?
How do you remove a turbo from a Renault megane diesel 1.9?
how do you remove a turbo from a 2005 Renault megane 1.9 dci
Remove heater matrix Renault espace?
with a gallon of petrol and a lighter lol, or i can give you the scrap man's number that i used.
How can you remove the inner constant velocity joint from the gearbox on a Renault espace 1994?
There is an inner joint roll pin holding the CV joint onto the shaft of the gearbox. You will need to use a arallel pin punch of suitable diamiter to knock out the driveshaft roll pins at the transmition end. Note there are Two roll pins one inside the other.
How do you remove the inside door cover of a Renault espace?
2 screws at bottom take cover off grab handle remove 2 10m bolts
Where is Renault espace windscreen wash bottle?
at the front o/s wing! you will need to remove the plastic wheel arch guard to get to it.
How do you remove glow plugs from Renault Espace 2.2TD?
hi there you have to remove the top engine mount and inlet manifold about 15 bolts its a bit potchy to get out and then you can get at the heater plugs
How do you change spark plugs on a Renault espace?
2 ways easiest is too remove inlet manifold other is too remove engine 3 ltrs only
