Head Gaskets and Valve Covers
1982-1994 Chevy Cavaliers
1995-2005 Chevy Cavaliers

Putting a head on a 94 Chevy Cavalier?

101112

Top Answer
User Avatar
Wiki User
2008-04-20 01:28:26
2008-04-20 01:28:26

You'll have to get to the head that you want to replace by removing everything blocking where you need to get at. Then you remove all the head bolts, the gasket, clean the engine block so that it is nice and smooth, put a new gasket on, put the head on, and torque the headbolts in the correct order and correct torque specs.

1
๐Ÿ™
0
๐Ÿคจ
0
๐Ÿ˜ฎ
0
๐Ÿ˜‚
0

Related Questions

User Avatar

firing order for Chevy cavalier

User Avatar

Yes it should. cavalier/corsica 90-95; most parts will be interchangeable.

User Avatar

if it is the same motor yes, but some may have different mounts or wiring plugs

User Avatar

it is a four bolt square pattern.

User Avatar

how do you fix your lighting problem with your 94 chevy cavalier z24 you haveno tail lights dash lights or parking lights

User Avatar

Worn rings, burnt valve or blown head gasket. also the timing chain could also be broken

User Avatar

why bother, spend your money wisely. vehicles can be the worst investment you make.

User Avatar

you have to remove the oil pan and replace the pump

User Avatar

located inside the gas tank. The fuel pump is located in the gas tank on my 94 cavalier convertible and so are all of the other models

User Avatar

82 to 94 as per a haynes manual, auto trans: 700 rpm and manual:750 rpms.

User Avatar

There is no standalone "power steering belt" on a 94 cavalier, just one long serpentine belt. There is a diagram in front of the motor on the passenger side right next to the prop rod. That diagram shows proper belt routing.

User Avatar

Chevy did not build Malibu in '94

User Avatar

All Cavaliers from '94 to '04 use a 3/8 Allen key on calipers.

User Avatar

The belt tensioner for a 94 Cavalier is mounted on the front of the engine. The tensioner is spring loaded on an arm to keep the belt tight.

User Avatar

YES IT will fit right in. No problems.

User Avatar

All Cavaliers from '94 to '03 used 3/8 Allen key on calipers.

User Avatar

yes it does have abs brakes

User Avatar

Shouldn't need to remove the box; just open it's cover and pull & replace the bad fuse.

User Avatar

All Cavaliers from about '94 to at least '04 use a 3/8 Allen key for calipers.

User Avatar

located in the block between the oil pan and cylinder head or the head itself middle way of the engine depending on the engine that ypu have

User Avatar

how can i repair a 94 chevy k1500 tailgate latch. cannot open gate

User Avatar

I have a knocking noise near the water pump pully or idler arm pully on my 94 chevy cavalier 2.2 motor when its at idle, if i give it more gas the noise will go away do you know what this could be? i took off the tension idle pully and checked the bearing and it was fine.

User Avatar

I just got both brake lines on a 94 cavalier replaced for $250.00. I dont know if this was a good price though.

User Avatar

Disconnect the - battery terminal Raise and support vehicle if necessary remove wiring from top of starter Remove mounting bolts Remove starter


Copyright ยฉ 2020 Multiply Media, LLC. All Rights Reserved. The material on this site can not be reproduced, distributed, transmitted, cached or otherwise used, except with prior written permission of Multiply.