0
Do yourself a favor have them check your new alternator before taking it home? I had a bad incident that I ended up with, 3 bad alternators in one day, 3 different stores. Last store check it before I took it home and everything was good. I ended up changing it 3 times. Make sure they also change the pulley. Alternator Removal & Installation 1. Disconnect the negative battery cable. 2. Rotate the drive belt tensioner away from the drive belt and remove the drive belt from the alternator pulley. 3. Detach the electrical harness connectors at the alternator assembly. 4. Disconnect the positive battery cable and remove the nut and washer. 5. Remove 2 front alternator bolts. 6. Remove the rear alternator support bracket retaining bolts and the support bracket. 7. Remove the alternator from the vehicle. To install: 8. Place the alternator in position and loosely install 2 front alternator retaining bolts. 9. Install the alternator bracket and 3 alternator bracket bolts. Tighten to 84 inch lbs. (10 Nm) 10. Tighten 2 front alternator retaining bolts to 19 ft. lbs. (26 Nm). 11. Connect 2 electrical hardness connectors to the alternator assembly. 12. Connect the positive battery cable and install the nut and washer. Tighten the nut to 72 inch lbs. (8 Nm). 13. Rotate the drive belt tensioner away from the drive belt and install the drive belt on the alternator pulley. 14. Connect the negative battery cable. 15. Start the engine and check for proper charging system operation.
What else can I help you with?
Where is the alternator fuse on a 1997 expedition?
I have a 1997 ford expedition that the alternator is not charging the battery. Had the alternator tested and it was good the battery is new. Cant find the fuse for the alternator does anyone know where it is?
Where is the voltage regulator found on a 1997 Ford Expedition?
Inside and integral to the alternator.
How do you release tension bar to replace alternator 2003 ford expedition Eddie Bauer 5.4 liter 4wd?
need to replace alternator on a ford expediting 2003
How do you replace an air conditoner filter on a 1997 Ford Expedition?
If you mean "cabin air filter," there is not one on the 1997 Ford Expedition. I have a '97 Expedition Eddie Baur and have looked and researched thoroughly.
1997 ford expedition battery light comes on and goes off when accelerated?
more than the alternator diode is bad have the alternator checked
How do you replace the rear axle studs on a 1997 ford expedition?
take the axle out
Why do your headlamps flicker while accelerating on a 1997 ford expedition?
Bad ground or alternator stating to go bad.
How do you replace the alternator on a 2000 Ford Expedition 5.4L?
take off old alternater and all attachements including wireing replace withe new alternator replace all attachments including wireing
How do you fix a 1997 ford expedition fuel filter?
You don't fix it, you just replace it.
Can you take a catalytic conerter out of a 1997 ford expedition?
Only to replace it with a new one
How do you replace the bulb for the check engine light on a 1997 ford expedition?
Very carefully
Where is the alternator fuse for the 1997 Ford Expedition?
the 20 amp alternator field minifuse is loosley connected below the lower 175 amp alternator megafuse on the firewall next to the battery.
