2001 Lincoln Ls Suspension Recall 00V359001NHTSA: Action Number: N/A Service Bulletin Number: 00V359001
Nov 03, 2000
Suspension
82300
Ford Motor Company
Summary: Vehicle description: passenger vehicles. The front suspension lower ball joints were not tightened to specifications when they were attached to the lower control arms.
Consequence: If the ball joint attaching nuts are not adequately tightened, they can loosen and, ultimately, result in fracture of the ball joint stud. If the ball joint fractures, control of the vehicle could be affected, increasing the risk of a crash.
Remedy: Dealers will inspect the torque on the two ball joint attaching nuts. Vehicles with loose ball joint attaching nuts will either have the fasteners tightened to specification, or if necessary, the ball joints will be replaced.
Notes: Owner notification began november 24, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
It must be replaced as an assembly with the entire steering knuckle. If you check ebay, there might be just the ball joint for sale, but it will need to be pressed into your old steering knuckle.
You need to have a "Ball joint press".
It's roughly only $20.00 more to replace the whole lower control arm that the ball joint sits in. It will save you alot of grief of pressing out old joint and pressing in the new one.
how do you replace the drivers side drive shaft and cv joint?
Replace the complete halfshaft assembly, it is much easier than trying to replace the cv joint itself.
The CV joint in a 2000 Kia Sportage can be replace by roving the tires, axle nuts, and the knuckle bolts on the struts. Next, the CV joint can be removed by placing a screwdriver between the transmission and the CV joint will pop out.
A 2000 Lincoln Town Car doesn't have a rack and pinion steering.
I changed mine, as the dealer was way out of order price wise. The trick is to remove passenger side tire and put jack stand under ball joint and then lower your lift so that the lower control arm with ball joint takes the weight. You then can rotate the alternator enough to remove from underneath the car. Be sure when replacing the upper bolt, that it goes through the correct mounting hole for the bolt.
The average cost to repair a CV joint on a 2000 eclipse is about $125. As for the half axle, this might cost about $30.Ê
$560 /joint pluse labour 2.5 hours Good luck it cost me $1000 dollars and they are pretty common to break again. The suspension is very sensitive
It is easier and cheaper to replace the entire axle. About $80.
days maybe weeks