The overdrive off light flashing indicates that a problem with your
transmission has been detected. Take it to the dealer or a transmission
shop and get it checked out. If you continue to drive the Explorer with
the O/D OFF light flashing you can possibly damage the transmission.
Ford has issued a TSB on this problem. Has to do with a transmission oil pump defect and repair procedure.
Article No.: 97-22-4
Date: 10/27/97
Transmission - A4LD, 4R44E/4R55E, 5R55E - Torque Converter Slip - Diagnostic Trouble Code (Dtc) 628 Or P0741 Stored In Memory
Ford:
1985 to 1993 Mustang
1987 to 1988 Thunderbird
1988 Cougar
Light Truck:
1985 to 1990 Bronco II
1985 to 1997 Ranger
1987 to 1997 Aerostar
1991 to 1997 Explorer
ISSUE:
Some vehicles may experience excessive torque converter slippage, torque converter not engaging, or Diagnostic Trouble Code (DTC) 628 or P0714 stored in memory. This may be caused by damage to the fluid pump support seal and/or to the groove on the pump where the seal is located.
ACTION:
Inspect the fluid pump seal for damage. Refer to the following Service Procedure for details.
SERVICE PROCEDURE:
1. Follow normal diagnostic procedures as listed in the appropriate Service Manual.
2. Inspect the fluid pump support for damage. If damaged, also inspect the fluid pump support seal groove on the pump.
3. If the groove is damaged, replace the pump.
4. If the groove is not damaged, replace the fluid pump support seal with a redesigned Seal (F77Z-7L323-AA). Refer to Figure 1.
5. Do not replace the torque converter unless it is damaged or fails the criteria listed in the appropriate Service Manual and/or refer to TSB 96-26-12.
your transmission is about done, sell it
The overdrive off light will flash in your gauge cluster when a malfunction has been detected by the powertrain control module
if you have overdrive in that car it means that your about to go into overdrive
Overdrive is the normally allowed position so you don't see the light on If you turn OFF the overdrive , the overdrive off light will light up or if there is a problem the overdrive off light will flash
When the overdrive light blinks that means a malfunction has been detected - get it checked out
The overdrive light to flash on 2005 Ford Expedition is caused by either the sensor problem or the electronic pressure control problem for the tranny.
When the overdrive off light is blinking that means a malfunction has been detected
A malfunction has been detected
A malfunction has been detected
The overdrive off light flashing - indicates a malfunction has been detected
A malfunction has been detected
A malfunction has been detected