Home
How do you fix a heater core on a cavalier 1991?
Wiki User
Answered 2005-09-25 16:39:46
Replacing A Chevy Cavalier Heater Core Q. I have a 1997 Chevy Cavalier, automatic, 4 cylinder with A/C, floor shift console, 4 door sedan that I need to replace the heater core. I need instructions or pictures of how to dismantle the dashboard to install this. Any help you could give me would be greatly appreciated. Thanks, Rick Replacing A Chevy Cavalier Heater Core A. Well, the first thing you have to do is take out the instrument panel. Replacing A Chevy Cavalier Heater Core Remove or Disconnect 1. Negative battery cable. 2. Instrument panel. 3. Drain cooling system. 4. Raise vehicle. 5. Heater hoses from heater core. 6. Lower vehicle. 7. Heater core outlet. 8. Heater core cover. 9. There is a mounting screw located in a recess in the center of the cover. 10. Heater core mounting clamps and heater core. Install or Connect 1. Heater core and heater core mounting clamps. 2. Heater core cover. 3. Heater core outlet. 4. Raise vehicle. 5. Heater hoses to heater core. 6. Lower vehicle. 7. Fill cooling system and check for leaks. 8. Instrument panel. 9. Negative battery cable. Replacing A Chevy Cavalier Heater Core 1. Valve Housing Cover 2. Heater/Blower Module Bolt 3. Defroster Valve 4. Mode Valve 5. Heater-Vacuum Tank 6. Heater Module Mounting Bracket 7. Heater-Control 8. Heater Valve Lever Link 9. Defroster Valve Actuator 10. Heater Case 11. Heater Valve 12. Mode Valve Actuator 13. Temperature Valve Clip 14. Temperature Valve 15. Heater Core Shroud 16. Heater Core 17. Heater Core Strap 18. Heater Cover 19. Heater Outlet 20. Heater Core Shroud Seal 21. Heater Core Tube And Mount Seal 22. Heater Core Seal 23. Heater And A/C Control Switch Harness 24. Defroster Duct 25. Blower Motor Bolts 26. Blower Motor Isolator 27. Blower Motor 28. Blower Fan 29. Blower Resistor 30. Heater Case Seal 31. Blower And Air Inlet Case 32. Mounting Seal 33. Air Inlet Housing 34. Vacuum Harness http://autorepair.about.com/library/faqs/bl503f.htm
Your Answer
Still Have Questions?
Related Questions
How do you replace a heater core on a 1991 Camry wAC or is it insane to try for a backyard mechanic?
how to fix 92 camary heater core
How do you fix a heater core?
The only fix for a leaking heater core is to replace it.
The heat does not work at all. How much would it cost to fix a heater in a 1992 Chevy cavalier?
$52- $208 roughly. depends on if the heater core is bad.
How do you fix a 1986 Buick riviera heater core?
Not practical to try to fix a heater core. Replace it with a new one.
How do you fix the heater core in a 94 geo?
You cannot fix or repair a heater core you must replace the complete unit with a new one...........
How do you fix the heater core?
fixing a heater core requires replacing heater core not knowing what vehicle you are asking about, that's all the information i can give
How do you fix heater core in 2000 new beetle?
In order to probably repair the heater core in your 2000 New Beetle, you will probably have to get the entire heater core replaced.
Where is the heater core located on a 2000 Concorde and how can you fix it?
The heater core is underneath the dash in the middle section right behind the console. You can fix it by removing the dash.
Your heater blows cold in your Lincoln?
COULD BE A BAD HEATER CORE COULD BE A BAD HEATER CORE sounds like the heater control switch needs replacing.if that doesnt fix it, you need new heater core
How do you replace a heater core in a 1998 Ford Ranger manual transmission 2wd?
Take it to a mechanic and say "will you fix the heater core?"
How hard is it and how do you fix a 1986 Ford Thunderbird heater core that is blowing steam even when the heat is off?
Replace the heater core. It is leaking.
How do you fix a 1992 Toyota 4runner heater core?
How do you bleed the heater after changing coolant in a 1992 4runner
How do you fix a bent front axle on a 1991 Chevy Cavalier?
You don't, you replace it.
Why would the AC vents be smoking?
The heater core or air conditioning core is broken and leaking fluid into the heating unit. simple to fix. just install a new heater core.
How do you fix jaguar s type heater?
To fix a Jaguar S type heater, check the diverter mechanism. It shunts air through the heater core, which may not be operating properly.
Your 1993 achieva is pouring coolant through a drain from an ac line close to the heater core If you bypass the heater core will it fix the problem without harming the ac?
Yes, but you will have no heat. Your heater core is leaking and needs replacing.
How do you fix heater on 2000 grand marquis?
is your heater core bad or thermostat bad need more details
How do you change a heater core on a 2003 Mazda tribute?
The heater on the 03 Mazda Tribute is going in and out. What is the problem and how can it be fix?
How do you fix the heater core in a 92 Pontiac Sunbird?
I would suggest replacing it.
How does one fix a 1994 Cavalier when the heat doesn't work except for the first time it is driven after the antifreeze is added or changed?
your heater core might be plugged(probable), or thermostat may not be opening all the way
How do you fix a car heater that blows cold air?
Check coolant level? Heater core plugged or restricted? Heater core airbound? Bad thermostat? Water pump not circulating coolant? Heater control cable not adjusted properly?
How much to fix leak in the heater core?
I don't recommend fixing a leaky heater core. Replacing with a new one is your best bet. Heater cores sell for aprox $40 and labor depends on the vehicle.
How do you fix a leaky heater core in a 1996 ford ranger?
Replace it with a new one.
How do you replace the heater core on a Chevy spectrum?
Why would you fix a Chevy Spectrum? lol!
Where is the heater core on a Dodge Dakota 1998 Sport?
This is my son-in-laws truck. I have to fix it
Still have questions?
