answersLogoWhite

0


Best Answer

** Be sure to have your wheel locked in the straight position and the key removed to avoid damage to the slide contacts for the airbag system. First, there are two fittings you need to remove, these are the high pressure and return lines located on the drivers side of the rack near the steeering shaft connection (follow the lines to the fittings, it isn't easy getting at these). Next, remove the rubber boots on either side of the rack and unscrew the inner tie rods. Now, you will see two large bolts through the K member, you have to remove the nuts (holes to access the nuts are cut in back of K member) leave the bolts in, to hold the rack up for now. You now have to remove the pinch bolt from the steering flexishaft. this is accessed from the opposite side of the k member near the drivers tire. pulll the bolts out now, the rack will be free and should come down with a little twisting and turning. If the lines on the rack itself are leaking you can call a Ford dealer and order them pre-bent and flared with fittings for about 8 dollars apiece... (been there)

User Avatar

Wiki User

โˆ™ 2011-09-12 21:01:54
This answer is:
๐Ÿ™
0
๐Ÿคจ
0
๐Ÿ˜ฎ
0
User Avatar

Add your answer:

Earn +20 pts
Q: How do you replace the rack pinion on a 1995 Ford Thunderbird?
Write your answer...
Submit
Related questions

Where are the vacuum lines on a 1995 Ford Thunderbird?

Where are the vacuum hoses on a 1995 ford thunderbird 4.6l engine?


What obd system is used on a 1995 ford thunderbird?

A 1995 Ford Thunderbird is OBD I , EEC IV


Is it necessary to remove the fuel tank to replace the fuel pump on a 1995 ford thunderbird?

Yes


What is the horsepower for a 1995 Ford Thunderbird 4.6?

For a 1995 Ford Thunderbird , 4.6 : I believe that is rated at ( 205 horsepower from the factory )


How much horse power does a stock 1995 Ford Thunderbird Lx V8 4.6L have?

how much hp does 1995 ford thunderbird have


Where is ecu for a 1995 Ford Thunderbird?

in the trunk


Does 1995 Ford Thunderbird have a cabin filter?

no


What kind of gas does a 95 Ford Thunderbird take?

For a 1995 Ford Thunderbird : ( " regular " unleaded gasoline , 87 octane )


Are 1995 and 1996 Ford Thunderbird hoods interchangeable?

No


How do you change the rear tail light on the trunk of a 1995 Ford Thunderbird?

Replace the whole light assembly Their are no bulbs it is neon light


What year did the Ford Thunderbird come out?

1995The first year for the Thunderbird was 1955. That first Thunderbird was the most popular model.


Can you use a transmission from a 1995 Ford Thunderbird LX V6 in a 1995 Ford Thunderbird LX V8?

no....the answer is no. sure you can all the 95s have the same trans would be a direct swap


Where is the heater core on a 1995 Ford Thunderbird?

behind the dash....


What size speakers are in a 1995 Ford Thunderbird?

6"X8"


What size is the gas tank on a 1995 Ford Thunderbird?

The ( 1996 ) Ford Thunderbird Owner Guide shows ( 68.1 liters / 18.0 U.S. gallons )


What is the cause for a 1995 Ford Thunderbird LX turn signals and flasher not working?

you may need to replace the flasher relay it should be in the fuse panel


What can you do if your car door handle broke on the passengers side of your 1995 Ford Thunderbird and you can not open your door?

I would find a replacement in a salvage yard and replace the handle. Or replace with door poppers


Where is the O2 sensor in a 1995 Ford Thunderbird?

where is (are) the location(s) of the oxygen sensor(s) on a 1995 Ford Thunderbird V8 ? I know where the front ones are I just can't seem to find the rear ones.


Where does the trunk drain hoses go on a 1965 Ford Thunderbird?

How do you replace the trunk drain hoses on a 1965 thunderbird.


How do you replace the headlights in a 1995 Ford Thunderbird?

Hi everyone, welcome to information about the COOLEST website ever: honeoye.webs.com... you even become a member VISIT NOW!


How do you replace wiper blades on A 1995 ford thunderbird?

Purchase new blades from your local auto parts store and they will install them for free (and you get to see how it's done).


How to change a timing belt on a 1995 ford thunderbird 4.6l?

A 1995 Ford Thunderbird , 4.6 liter V8 engine has ( 1 ) timing CHAIN to each cylinder head ( 2 timing CHAINS in total )


Will the struts and springs from a 1999 thunderbird fit a 1995 linclon mark 8?

nope ford did not produce a thunderbird in 1999


How do you remove a rack and pinion from 1996 Ford Explorer?

I AM TRYING TO REPLACE A RACK AND PINION IN A 1997 FORD EXPLORER COULD YOU TELL ME OR GIVE ME A PICTURE ON HOW THE OLD ONE COMES OUT>


Is there a heater core on a 1995 Ford Thunderbird?

yes. it is located behind the dash