you use a long fine threaded bolt usually from a gear puller and insert it into where the bolt comes out of the clutch in the center and tighten the long bolt up usually with a impact wrench and the clutch will come off if the clutch is set up like the snowmobiles and the variable speed atvs
The above method will more then likely cause damage on ATVs that never had the primary clutch removed. in that case tip scrambler on its side and fill hole up with some heavy gear oil, using a fine thread bolt (or removal tool) wrapped with Teflon, begin to thread it in, it will use the hydraulic pressure to "pop" the clutch off. be prepared because it will fly off, one hand on clutch and other on wrench. works on any polaris primary clutch
To adjust the transmission belt on a 2001 Polaris Scrambler 500 4x4, first, ensure the vehicle is on a flat surface and the engine is off. Remove the clutch cover by unscrewing the retaining screws, then check the belt's wear and tension. If the belt is worn, replace it; otherwise, adjust the belt by loosening the clutch mounting bolts and repositioning the clutch for proper tension. Finally, reattach the clutch cover and ensure everything is secure before testing the vehicle.
1. Remove belt/clutch cover 2. Pull out old belt, should pull in easily at secondary sheave, spimply walk it out then remove it from primary 3. Inspect all clutch components - anything is out of spec repair it 4. Install new belt in similar reverse order 5. Check/adjust belt deflection (by shimming secondary) 6. Install clutch cover 7. Test drive
Remove belt cover from left side of engine . If you remove the screws that hook rear fender to foot rest the cover comes off easier . Then take out bolt in center of rear clutch assy . Slide rear clutch off and remove old belt .Install new belt in reverse mannor .
A picture of the clutch assembly removal process for a 250 Polaris Trailblazer can be found in the repair manual. It details how to access, disassemble, and remove the assembly.
Remove the bolt from the crankshaft. You will need a puller to remove the clutch. I can tell you how to make one, Let me know.
Disconnect the positive cable from the battery. Disconnect the cables from the starter. Remove the starter retaining bolts. Pull the starter out.
remove clutch cover. remove old belt. install new belt.
You have to have a special tool. It mounts to the side of the flywheel, then you screw the bolt into the plate onto the center shaft and it pushes it off...
Remove the clutch cover , you might have to remove the left floorboard to remove the cover . The rear clutch can easily be removed by removing the bolt in the middle and pulling it straight outward . The front clutch requires a puller that screws into the center of the clutch .Removal without a puller will result in clutch damage .
The drain plug for the crankcase on a 1997 Polaris Scrambler 400 is typically located on the bottom of the engine case. You may need to remove the skid plate for better access. Look for a hex or bolt-type plug, which is often positioned towards the rear of the engine. Always ensure to have a drain pan ready to catch the oil when you remove the plug.
You have to pull the front clutch off to get to the rest of the bolts...
You will need to remove the transmission. Remove the clutch plate retaining bolts. Remove the clutch linkage. Remove the clutch retaining bolts.