Jan 29th 2008 (68 Mustang Coupe Heater Core Replacement)
289 factory air (without the air conditioning pump etc)
1. Remove Glove box to get better access (3 bolts on bottom)2 Disconect vacum lines, wires and cable (mark for reinstall)3 Disconect drain hose (bottom of box to floor)4. Unbolt water hoses from inside engine compartment5. Locate 2 nuts on firewall that loosen compleate heater box6. Twist and rotate to drop heat core box.7. Take box apart (diagram how everything comes apart)........(be careful to save all rubber, might need later)8. order seal set and appropriate heater core .......(mine was for a car with a/c)9. Glue foam and rubber seals back into original position .......(used 3M spray glue)10. Make sure core is situated properly in box........(old rubber worked better in some spots)11. Lift and twist to get box back up into position........(this took the most time, to align thru firewall)12 Reconect all vacum lines, plugs, wires and cables to original position (Glad you marked them when taking apart!)13. Reconect Hoses14. Reinstall glove box
robbpynes@continet.com
For the HEATER CORE ? No
Big job!! get a manual on your car.
Best to get the shop manual but basically: Reomove Heater hoses from engine block and drain. Remove glove box. Disconnect cables that connect to heater core. Disconnect heater core from firewall. Disconnect hoses from heater core. Pull heater core from under dash.
How do you replace the heater core on a jimmy?
how do u replace the heater core
The heater control valve in a Mustang is located within the engine. It is right in the heater's core and where the coolant is located.
The heater matrix, in a Peugeot 206, can be replaced by removing the heater core and the hoses. With the heater core removed you can replace it with a new heater core.
How do you replace a heater core in a 1998 Ford Expedition?"
how do you replace a heater core in a 91 Oldsmobile 98
How do you replace a heater core in a 1998 ford expedition?"
how to replace a heater core in a 1997 Chevy blazer
replace heater core on 92 buick century