0
1995-2005 Chevy Cavaliers
The 1995-2005 Chevy Cavalier was the third generation Cavalier model produced by General Motors. In 1996, the Cavalier Z24 received the new LD9 2.4 liter engine along with the Getrag F23 5-speed manual transmission.
7,016 Questions
What are torque specs for 2000 Chevy cavilair 2.4 main bearings?
Main bearing cap bolts 2.3L-2.4L Step 1 15 FT-lbs Step 2 Tighten an additional 90 degrees....Connecting rod cap nuts Step 1 18 Ft-lbs Step 2 Tighten an additional 80 degrees
How do you install starter on a 1999 cavalier?
Note:It may be necessary to remove the exhaust pipe(s) or frame crossmember to gain access to the starter.In extreme cases it may be necessary to unbolt the mounts and raise the engine slightly to get starter out
- Disconnect the negative battery cable.If the vehicle is equipped with a delco loc 2 or theftlock audio system make sure to have the activation code before disconnecting the battery.
- Raise the front of the car and support it securely on jackstands.Apply the parking brake and block the rear wheels.
- On 2.2L engines with manual transaxle remove the brace between the engine and the transaxle.On 2.3L and 2.4L OHC engines remove the air intake ducts to gain access to the top starter motor bolt locatedon the transaxle
- Remove the mounting bolts and detach the starter.Note the location of the spacer shims they must be reinstalled in the same position (if used)
- Working under the car clearly label then disconnect the wires from the terminals on the starter motor and solenoid
- Installation is reverse of removal
How do you change out clutch pressure plate and throw ou brearings in a 1996 cavalier?
TEAR IT APART AND THROW THE OLD ONE OUT AND OPUT THE NEW ONE IN
How do you remove steering wheel on a 2004 Chevy?
It can be hard to remove a steering wheel by hand on any vehicle. To remove it, there is a tool, steering wheel puller, that can be bought or rented from local auto shops. It will help remove the steering wheel.
How do I fix Cavalier dash rattles?
Bash it with a rubber mallet while it is rattling. Seriously. Mine stopped.
How do you replace a 1999 cavalier heater core?
Caution:On models equipped with Delco-Loc 2 or Theftlock audio systems make sure you have activation code * Disconnect the negative battery cable * Drain the cooling system * Disconnect the heater hoses at the heater core inlet and outlet on the engine side of the firewall and plug the open fittings * From the inside of the car remove the lower right dash insulator panel and the glove box * Disconnect the ducts from the heater cover * Remove the instrument panel from the passanger compartment * Remove the heater core cover * Remove the heater core clamp bolts and clamps then slide the heater core out carefully * Installation is reverse of removal
check your coolent fill cap
Where is the oxygen sensor on a 2000 cavalier?
The upstream oxygen sensor is mounted in the exhaust manifold The downstream oxygen sensor is mountedin the exhaust pipe after catalytic converter
Valve lash is the gap between the rocker arm and valve stem on cylinder heads. Proper adjustment ensures that a vehicle operates at peak performance.
How do you replace the battery on Chevy cavalier?
near the bottom of the battery there is a bolt through a rubber tie down looks like this /o\ un bolt that remove the terminals and lift it out
How much oil do you put in a 2003 cavalier 4 cylinder 2.2 liter engine?
my 2.2L 1999 cavalier takes 3.7 quarts of 5w-30 oil. use castrol at wal-mart stores. look at owners manuel or go to autozone.com.
The 2003-2005 cavaliers have the 2.2 Eco-tec motor which takes 4 and a half to 5 quarts of oil. the Idea was to give it more miles between oil changes but with the new filter they used it really should still be changed every 3,000 miles.
What is the loud noise in the rear of car when you come to a stop?
Something to check would be if there is rust in the break-drums that would need to be cleaned. Another possibility would be the strap around the muffler. Check to make sure it isn't broken. If it is, the muffler may be hitting part of the frame, hence the noise. Other than that, I have no idea.
Where is evap canister on 2002 cavalier?
They were only put two places depending on the model. Right front fender and next to the fuel tank.
What does it means when the trac off light come on and stays on a 2002 Chevrolet Cavalier?
It could mean many things. You will have to pull the codes to see which area to go after. But if no codes are present,you should suspect the wheel sensors. Go to salvage yard,get one,then go to each wheel,unplug it and plug in the one you just got.See if the light goes off.Be sure to turn off the key and back on after EACH wheel.
Is there an inside access panel to access the fuel pump on a 2003 cavalier?
No, but what a wonderful ideal....
