Chevy Express

Park the vehicle on a level surface. Drain the oil and replace the filter. Add 4.5 quarts of oil and start the engine. Run for 1 minute and shut the engine off. Wait one hour and then check the oil level. Add enough oil to reach the full mark. You now know what the capacity is.

The front track of the 2005 Chevrolet Express-Cargo is 5 ft. 7.8 in. (67.8 in.).

There are 2 fuse boxes: one under the hood on the drivers side, and the other is under the drivers seat... they both have black plastic covers that can be removed without tools.

change the p/s pump. the pump helps the hydro booster with braking.

On the passenger side tank at the bottom of the radiator, engine side.

The differintial is starting to wear...

take it to the autozone they check the engine light for free

The maximum tosing capacity of the 2003 Chevrolet Express is 6400 lbs..

In the fuel tank

ok, first you have to take the housing off. Gain access to the housing by unscrewing the two screws on the pannnels to either side of the housing. (one is under the stering wheel the other pannel is right in front of passenger) Next remove the front console by opening the console door and pushing the little rubber piece out of the way to remove the door.

There are four bolts to remove. These are a different color than the other bolts you have. they are the long ones. Once you pull off the console you should see the front two latches, oopen them and the latches up top.

VOILA.. volaa..vo. ok good for you - now the fun part is over except.. you need to take the front left tire off... i am not kidding just do it. The unreachable spark plug is now in reach.. you just have to go up under wheel well. (It would help if you had the powers of plastic man too) ... good luck with the rest of the job

The blower motor speed resistor is burned out. The resistor is located close to the blower motor and is easy to change. Your local auto parts store will have that part for you.

Follow the upper radiator hose from the radiator to the engine. Where the hose is attached at the engine is the thermostat housing. Drain some coolant from the radiator thru the petcock, remove upper radiator hose from thermostat housing, remove thermostat housing then remove the thermostat. On the Express van you will probably need to remove the air filter assembly to gain room to work.

In a 2003 Chevy Express van, the relay for the air conditioning (AC) system is typically located in the under-hood fuse and relay box. This box is situated near the battery on the driver's side of the engine compartment. You can identify the specific relay for the AC by checking the diagram on the cover of the fuse box. If you're having trouble, consult the vehicle's service manual for detailed information.

The Gross Vehicle Weight (GVW) of a Chevy Express 2500 Cargo van typically ranges from about 8,600 to 9,300 pounds, depending on the specific configuration and options. This weight includes the van itself, plus the maximum load it can carry. It's important to check the manufacturer's specifications for the exact GVW as it can vary based on the model year and specific features.

For a 2005 Chevy Express, you typically need a 7mm or 10mm socket or wrench to remove the caliper guide pin bolts, depending on the specific brake system installed on the vehicle. It's best to check your vehicle's service manual for the exact size, as variations can occur. Additionally, having a torque wrench on hand for reinstallation is recommended to ensure proper tightening.

The solenoid sensor in a Chevy Express G25 van is typically located on or near the transmission. Specifically, it can often be found mounted on the transmission case, usually towards the front or side, depending on the specific model year and transmission type. To access it, you may need to remove some components for better visibility and reach. Always refer to the vehicle's service manual for precise location details and procedures.

On a 2006 GMC Yukon, the blower resistor is typically located under the dashboard on the passenger side. It is usually mounted on or near the blower motor housing, which is accessible by removing the lower dashboard panel. You may need to disconnect the electrical connector and remove screws or bolts to replace it. Always consult your vehicle's service manual for specific instructions and safety precautions.

The fuse box on a 2007 Chevy Express commercial van is located under the driver's side dashboard. You can find it near the steering column, typically covered by a plastic panel that can be removed for access. Additionally, there is a secondary fuse box located in the engine compartment, near the battery, which houses fuses for various engine components. Always refer to the owner's manual for specific fuse locations and diagrams.

In a 2009 Chevy Express van, the fuse for the right signal light is located in the under-dash fuse panel, which is situated on the driver's side. Look for the fuse labeled "Turn Signal" or "T/S" in the fuse diagram provided on the cover of the fuse panel. If the fuse is blown, replace it with one of the same amperage to restore functionality. Always consult the owner's manual for specific details regarding fuse locations and specifications.

The oil pressure gauge on your 2004 Chevy Express van 2500 may not be working due to a faulty oil pressure sending unit, which sends readings to the gauge. Other possible causes include a blown fuse, damaged wiring, or a malfunctioning gauge itself. Additionally, low oil levels or oil pump issues could affect pressure readings. It's best to diagnose the problem through a systematic check of these components.

Yes, you can bypass the transmission cooler on a Chevy Express 2500, but it's not recommended. Bypassing the cooler can lead to higher transmission temperatures, which may cause overheating and damage over time. If you're experiencing issues with the transmission cooler, it's better to repair or replace it rather than bypassing it altogether. Always consult with a professional mechanic for the best course of action.

Yes, BP Autran SYN 295 is suitable for use in a 1999 Chevy Express van, as it meets the requirements for automatic transmission fluids specified by General Motors. However, always check the owner's manual or consult with a mechanic to ensure compatibility with your specific vehicle's transmission type. It's also important to verify that the fluid meets the necessary specifications for your van's transmission.