0
Chevy Express
The successor to the Chevrolet Van and GMC Vandura, the Chevy Express is a full-size van produced by General Motors.
886 Questions
Where is the fuel pump 0n a 2002 chev express?
Look under the vehicle - follow the fuel line from tank - remove clamps and mounting to replace
How do you replace fuel pump on Chevy 2000 Express conversion van?
The fuel pump is in the gas tank. It is not easy , first before you do it make sure that is the problem.Get a auto manual if your not up to it take it to a good repair shop and be ready to pay $600.00 to $700.00 to have it done.
on those vans the conections usually go bad before the pump,check the wires under the van by the front of gas tank.this happend to me.
The best way to tell if it's working, is to listen for a sort "whine" for about 5-10 seconds when first turning the key to the on position without trying to start the engine. The noise you hear is from the fuel pump in the gas tank.
Having driven several of these vans over several years, 99% of the time, the failure will be the pump itself.
As far as replacement, if it's a cargo van and you're not too concerned about the floor in the van, I measured and cut a hole with a hole saw over the gas tank (carefully) where the fuel pump is located. Then I could pull the pump. No dropping of the gas tank, but you will have to cover the hole and seal it so that no exhaust fumes can leak into the van. I used a thick piece of metal, gasket material and sealer with screws for the next time I might have to do this. You also have to be careful you don't puncture the top of gas tank and a spark from drilling into it could be a "Ka Boom"!
They were a common failure problem.
Honda Sedans have a plate over the fuel pump in the gas tank in the trunk. Makes for easy replacement. Their pumps aren't cheap though. About $175
Fuse diagram for Chevy Express van?
go to Autozone online. They have repair info as well as wiring schematics
1999 cheverlet express van where is the blower motor?
Wild guess: On most GM vehicles it's under the hood, on the firewall, on the passenger side.
How can you get into your Chevy Express 3500 you locked your keys in?
A brick thru the window always works
1990 Bonneville won't start when cold but runs fine when hot plug in block heater or heated garage?
There are a couple possibilities:
Start with a fuel line de-icer in case you have a little water in the fuel and it's freezing. Water builds up from condensation, much the same as water builds up around your glass when it's hot in the summer. Gasoline manufacturers do NOT put water in your fuel, no matter what your "expert" friends say.
If that doesn't help, try a tune-up. Plugs & wires can sometimes help by giving a hotter spark. Starting cold is difficult on your engine and you need to make sure it has all the help you can give it.
Last, if nothing else helps, check the compression. If compression is low the engine will be difficult to start and nearly impossible when it's cold.
How do you move the driver's seat assembly back from the dash in a Chevy Express Van?
There is a horizontal bar under the front part of the seat. You pull it up and push back with your feet.
What is the weight of a captain's chair for a van?
Captain's chairs for vans can weigh anywhere from 40 to 75 pounds. The cost for a replacement chair ranges from $369 to $900.
Do the back of the Chevy Express van bench seats fold down?
Unfortunately the Chevy Express of 96 TO 02 does not have folding bench.
I don't know for others years.
How do you change the drivers side door handle on a 1998 Dodge Avenger?
== == Go to the Allpar.com site and search for an article by Rodger Koppa on how to do this nasty little job. Did it on both my doors, be prepared to cuss a bit. After you install the new handles you can forestall future breakage by just popping the lkatch with the handle, and then using the edge of the door to swing the door open. Those dinky plastic handles just can't take the side torque with those heavy doors! I used the directions provide by Rodger Koppa to repl;ace my passenger side door handle and it works great. Like he says though be prepared to cuss a little bit and just hope you don't drop anything into the door. Good Luck!!
Can you re-torque intake manifold bolts to stop a leak?
I did just that today on my son's 2000 Saturn SL1. It had a slight miss at idle speeds. After re-torqe the miss seems to be gone. I think he had a slight vacuum leak. Understand, I am no master mechanic. To have a new intake gasket installed by a mechanic would have run around $500. I figured that I had nothing to loose by trying. It seems to have helped and maybe solved the problem. I'm also going to run some fuel cleaner through the system. I'm sure that some dirt seeped past the leak. Make sure you don't tighten the nut so tight that it brakes.
Sincerely,
tjbsr2@yahoo.com
Please feel free to contact me by e-mail if this helps!
Where is the horn relay located on a 2000 Chevy Express van?
They hid it. Facing the vehicle it is located below and to the right of the master cylinder above the computer almost inside if the left fender. Should say Delco Fuse Center on it.
There trucks are notorious for steering column wiring problems. The issue is that the horn and air bag share the same wire passage. Got to be very careful.
What is the fuel pressure for 2000 CHEVY Van with 5.7 cu. in. engine?
Must have no less then 55 PSI. and no more then 62 PSI.
The specs. are 55 to 62 LBS. PSI.
How do you remove passenger seats in a Chevy Express van?
all you have to do is use common sense and your good to go!
How do you add freon to a 2004 Chevy Express?
Buy a kit at Wal-mART OR AUTO PARTS COMES WITH INSTRUCTIONS
Where is air flow sensor in a 1997 Chevy Express?
If you look at the air filter box, you will see the air intake hose that goes to the engine. As soon as it comes out of the box, it will be in that hose.
How do you open a 1999 Chevy Express van with no keys?
My helper locked the keys in my 2003 Express: I called AAA and they sent a locksmith. He used several plastic wedges along the top of the drivers door, creating a gap of about 2 inches between the door frame and the truck body. Using a stiff wire with a hook on the end, he caught the sliding lock button, and pulled...open in 2 min. max.
BTW: the door sprung back into shape on its own, and the paint wasn't even scratched!
How do you change spark plugs on a 2001 Chevy Express van?
High level description here: Changing spark plugs and wires in my 1996 Express was an all day project for me. It's been a few years, but I recall I had to take the front wheels off to get access. Be safe. I needed to get s 3", 6", and 12", socket wrench extensions as well as a universal joint. I'm pretty sure I used 1/2" drive sockets.
The motor cover in the passenger compartment needed to come out to get access to the distributor. I do not recall whether or not I got access to the rear plugs from the inside or outside.
I couldn't fathom why a garage wanted over $500 to change the plugs, wires, distributor cap. After I did the job I understood. Good luck!
