0
Chevy Express
The successor to the Chevrolet Van and GMC Vandura, the Chevy Express is a full-size van produced by General Motors.
886 Questions
What engine does purolator oil filter number L34631 fit?
Purolators website lists 815 applications for the L34631 oil filter for GM vehicles from 1964 to 2004 - various gas and diesel GM engines
Where is the radiator drain plug on a Chevy Express?
The radiator has a hard to see drain plug on the left drivers' side. There are 5 10MM screws holding the air deflector on. The block has removable plugs, one 14MM hex next to the oil filter and one in about the same location on the other side of the block toward the firewall under the exhaust manifold.
Where can I find the wiring diagrams for a 1999 Chevy Express Van 3500?
A person can get a wiring diagram for this car as a print out at an auto store. They can also find the wiring diagram in the maintenance manual of this vehicle.
How do you manually check 2003 Chevy Express van engine light code?
It takes a scanner to read the codes.
How do you charge the AC on a 2006 5.3L express van?
To charge the AC on a 2006 5.3L express van you locate the AC unit under the hood. The owners manual will have diagrams on the engine parts and the type of coolant needed to recharge the AC. You follow the instructions on the coolant.
Why does my van not start when i fill up the gas tank it's a 2007 Chevy Express van?
Does it start when the van is not so full? Sounds like the gas is plugging the tank vent.
How do you reset the security system on a 2000 Chevy Express?
1999 chev van 2500 5.0 liter engine run and stop
How do you remove interior engine cover Chevy express van?
It depends on the model year and size of engine cover based on the engine underneath. For 1996 and newer, you generally have to remove the passenger seat in order to get the cover out of the way.
How do you change fuel pump 2003 Chevy Express van?
To change the fuel pump on a 2003 Chevy Express van, first ensure the vehicle is safely lifted and supported. Disconnect the negative battery cable, then relieve fuel system pressure by removing the fuel pump relay and starting the engine until it stalls. Remove the fuel tank, disconnect the fuel lines and electrical connectors from the old pump, and replace it with the new pump. Reassemble everything, reconnect the battery, and test the system for leaks before starting the engine.
Where is the bank tow sensor one on 06 Chevy Express?
Bank two is the passenger side of the engine. Senor one is before the catalyst converter. The answer is passenger side exhaust manifold.
How do you replace passenger armrest on 2007 Chevy conversion van?
how do u replace passenger armrest on 2007 Chevy conversion van
What would cause an idler pulley to freeze up on a 2000 Chevrolet 1500 express van?
There is a small bearing in there and sometimes they just fail. The bearing can't really be changed so you'll have to buy a new or used idler pulley.
Where is the oxygen sensor located on a 2008 Chevy Express?
O2 sensors are always screewed into the EXHAUST system. Look at the exhaust from the engine alway back to the muffler and you will find them.
How much to tune up Chevrolet express van?
About $100 for iridium plugs, and wires for the 6.0L V8 engine.
2001 Chevy Express Van where is turn signal switch located?
The turn signal switch is located in the left side of the steering column attached to the turn signal arm. It is one unit with the 4 way flasher.
You need to run a fuel pressure test on the fuel pump. It must have 60 to 66 LBS. of pressure with key on and engine off. NO LOWER ARE HIGHER or you will have starting and running problems. You also need to check the fuel filter.
How do you know if the relay or the fuel pump?
GM cars have a test lead for the fuel pump. In the case of my Sunbird it is on the driver side, under the hood back where the wiring comes through from the fuse box. It's a red wire with a terminal end. It has no power running to it at all. You plug in a 12v source and if the fuel pump comes on then you know the pump is working and the problem is elsewhere.
