0
Chevy Express
The successor to the Chevrolet Van and GMC Vandura, the Chevy Express is a full-size van produced by General Motors.
886 Questions
How do the seats fold down in Chevy Express 3500 van?
There should be a little lever behind the seats. Pull up on this and then the seats will fold down for you.
How do you reset the oil change light on a 2003 Chevy Express?
turn the ignition key on and press the gas pedal 3 times, turn off the key, and start up as normal..this should do it....
How do you replace a drivers door handle on a 2002 Chevy Express?
this is for 1998 express 3500 with hand cranked windows and manual locks, but should be the similar. Note, getting the proper tools will make this easier
1. Remove the window cranks, get tool for this
2. Pop out the plate behind the door latch handle
3. Remove the 2 screws behind the door latch handle plate
4. Remove the bumper pad on top of the door pull handle
5. Remove the little quarter panel in front of the window and Slide the door panel up to remove it.
6. In the door panel is sub panel where the door latch is, remove it from the door panel
7. Carefully pull back the plastic sheet stuck to the door
8. In the way of the door handle is the rear guide for the window, there is one screw holding it in at the bottom, remove the screw and leave the slide inside the door
9. There are two black plastic caps behind the door latch, carefully pry them out, they will give you access to the 10mm nuts holding the door handle assembly together
10. Remove the 2 10mm nuts holding the door assembly together
11. There is a back plate inside the door, the door handle itself, a rod connecting to the door latch and another to the lock cylinder. Will need to pull the back plate first, it will only come out part way.
12. Next you will pull out the door handle, the sealant will have the handle stuck to the door very tightly. You may need to carefully pry the handle off the door.
13. Underneath the lock cylinder is two holds, put a small screw driver in the first hold to release the mounting lock and side the cylinder out.
14. Finish wiggling the door handle and the back plate apart
15. Disconnect the door latch rod. Twist the door latch rod to un-thread it from the latch at the other end. Look the the connector carefully and unlatch it so it is open for re installation.
Re installation is the reverse steps sort of
Put the assembly together outside the door first to see how the parts go together. This will be very helpful
1. Attach the door latch rod to the door handle
2. Position the lock cylinder for installation
3. Put the door latch half way in and position the back plate and then put them together/wiggle them together, remember how they looked with you assembled them outside the door
4. Put the 2 10mm nuts on loosely
5. Slide the cylinder lock in place, push it all the way in so the holding lock engages
6. Tighten down the 2 10mm nuts on the handle
7. Put the door latch rod into the plastic latch at the bottom and close the latch
8. Re-install black caps
9. Re-install the window slide
10. Put the plastic sheet back in place
11. Install the door panel
12. Install the sub panel in the door panel and screw in place
13. Insert the plate behind the door handle
14. Install the door bumper pad
15. Install the front window quarter panel
16. Install the window crank
Done.
1999 Chevy Express leaks water from intake?
You have to replace the intake manifold gaskets, which is not an easy job but if your mechanically inclined it shouldn't be a problem .disconnect the battery and i can not stress this enough, mark the distributors position to the engine block if not your computer will set a cam to crankshaft correlation trouble code.
Where is the fuel pump on a 1999 Chevy Express van?
Type your answer here... in gas tank, empty drop down tank after diconnecting all quick release connectors and its on top took me 3 hours and it was my first
How do you reset information panel on a 2008 Chevy Express Cargo van?
I disconnected the positive terminal of battery to remove buildup on connections to under hood fuseblock. cleaned connectedall terminals and van will not turnover. everything is lit up on dash but check engine and battery lite stay on. 2007 chevy express cargo van. thanks, Denny
What does it mean when the check engine light flashes in a 1997 Ford escort?
It means you have an engine misfre.
How tall is the 2006 Chevrolet Express-Cargo?
The height of the 2006 Chevrolet Express-Cargo is 6 ft. 9.6 in. (81.6 in.).
Why would the brake lights and dash go out when the headlights are turned on a 1989 Honda Prelude?
It may be wired wrong.
I too have a need for this answer == 2001 Holiday Rambler on
a Workhorse chassis -- replaced CATS and thought OK but after
1,500 miles -- again quit late afternoon -- Workhorse customer
service NO HELP -- they say maybe valpr lock, but current fuel
systems almost preclude vapor lock problems. HELP HELP
I'm at 30,000 miles -- problem started at 23,000 -- am 3rd owner
and bought at 22,000 last June 2006.
Nelson
972.953.6150 (C)
Nelson.com
How wide is the 2005 Chevrolet Express-Cargo?
The 2005 Chevrolet Express-Cargo is 6 ft. 7.4 in. (79.4 in.)12V front power outlet(s) wide.
Why does your 1999 Chevy express 3500 van shuts off when in warms up?
A 1999 Chevy Express 3500 van that shuts off when it warms up can have a bad fuel pump. It can also be caused by the distributor cap getting worn out.
Where can you find a wiring diagram for a 2000 Dodge Ram 2500 van to fix a brake light problem?
Haynes Manual usually have the wiring diagrams in them. Most auto parts stores (Advance, Auto Zone, etc) usually carry them.
Why doesn't a Chevy Express 3500 van not start?
If yes, check for air, fuel, and spark.
If you're missing any of those, it will not start.
Remove and dry inside rotor cap with hair dryer, look for crack on cap and most likely it does not have seal.
Try applying small amount of silicone to stop moisture in future.
How do you replace the left rear turn signal bulb on a 2009 Chevy Express?
2009 Chevrolet Express turn signal bulb replacement: Purchase the correct replacement bulb(s) first, before disassembling the vehicle. See sources and related links below for replacement bulb information. Then consult your owner's manual for the replacement procedure. As simple as it sounds, the owner's manual is the best place to start for bulb replacement instructions and illustrations. You may want to consider replacing both left and right at the same time in order to keep brightness and color equal (optional).
Look at the distributor cap and rotor button. Sometimes moister can get in there and corrode the points causing the van to not start. This especially happens when it rains alot and the van sits without starting. Hope this helps you. I almost put a fuel pump in but luckily checked this before I spent $800 to have a mechanic do it.
How do you wire a stereo in a 2003 Pontiac Aztek?
If it is not a factory stereo, you will need a GM class2 data bus interface device in order to keep other car devices active.
Why does your peugeot 607 have a front end wobble?
could need a tire balancing. Also check the tires to see if you dont have a bubble on one of them
Starter 1995 astro van Chevy replace?
The cost to replace a 1995 Chevrolet Astro van will vary depending on the labor costs and the part cost. The price for the starter starts at $46.00 dollars.
Where is the fuel filter located on a 2000 Chevy Express van?
Under the driver side of van just in front of the fuel tank along the frame just inside the frame rail.
