0
Chevy Express
The successor to the Chevrolet Van and GMC Vandura, the Chevy Express is a full-size van produced by General Motors.
886 Questions
Thats simple,due to experience..it's your cv joints,,worn out..but take notice, it can be from regular wear and tear,or due to soft motor mounts,creating undue stress on the inner joints.The motor actually twists to far and creates damage to the inner cv joint.I replaced top(driver's side mount)and the bottom mount.Installed new Cv's,,result is aok. Note:Most say the motor mounts are only good for 4-5 years,before replacement.
I had the exact same problem with my '92 Grand Voyager, a bad shake and wobble in the front end only when accelerating and was especially noticeable around 35-45 mph. I finally found a mechanic who knew exactly what the problem was. My c.v. joints were fine, the problem really was the motor mounts. They were badly worn (182,000 miles) and one of the mounting bolts was actually broken. He explained that the extra play in the motor mounts causes the c.v. joints to "bind-up" under acceleration. I'm no mechanic, but I do know that this fixed the problem. You will probably have to replace all three mounts to remedy the wobble.
On a 95 ranger, the 4wd actuator needed replacing. on a 95 ranger, the 4wd actuator needed replacing. However, you can put it in 4wd and tap the from housing and it will sometime go into gear. The lack of use causes the actuator to freeze-up.
How tall is the 2004 Chevrolet Express?
The height of the 2004 Chevrolet Express is 6 ft. 9.6 in. (81.6 in.).
Why would a 98 Lincoln Mark VIII LSC flood out when the engine is cold and not start?
Could be bad fuel injectors that leak when vehicle is parked for any length of time causing it to flood One very cold morning I again ran my battery down trying to start my Mark VIII. My wife started her SUV and jumped the battery for me. Her advice to me has solved the problem. DO NOT PRESS THE ACCELERATOR. Just turn the key and let the computer control the air fuel mixture. Now it works every time!!!!!
How do you change the time on the clock in a 2000 Chevrolet Express Van?
Press the set button then within 10 seconds, press the seek and scan buttons to change time.
Why does your 1999 Chevy Astro van keep cutting off?
I experienced this and discovered that the main coil wire from the coil pack (distributor module)was rubbing against the underside of the dog house (engine cover). The wire was worn almost flat at the point of contact. Thus causing the ignitin to short out. I replaced the wire and all is well. My 1998 Chevy G1500 conversion van has some of the same parts as your Astro. I had these symptoms and eventually the van cut off and stopped running completely. Call your local auto parts store and see if they will loan you a code scanner for the OBD under your dash by the steering wheel. You can plug the reader in, turn on the car, follow the reader's instructions and retrieve any trouble codes that might relate to the stalling. There may be no codes present, however, if the problem is the computer itself. I had to replace the ECM (Engine Control Module). The battery was fully charging and the voltage remained constant. The plugs and wires looked healthy. The distributer cap had no cracks and I had no other warning symptoms. The car simply died from time to time. Usually, it would restart and run fine after letting it cool down. I removed the ECM and opened it up to inspect the greenboards. There was a burned out section on the greenboard. I removed the knock sensor and bought a replacement ECM. The knock sensor had to be put back in the new ECM and the ECM had to be reprogramed specifically to my vehicle's VIN number. I had the part supplier program it for me for $70 I bought the mid-priced ECM in case the thing burned out again due to me missing the burn-out cause. After the replacement, there is an anti-theft, security override process that you have to follow so that the vehicle will start. Put your key in the ignition cylinder and turn it to the ON (RUN) position. The "security" light on the dashboard will flash for 15 minutes. When the security light stops flashing, turn the ignition cylinder to the OFF then back to the ON position. The security light on the dash will flash for 15 more minutes. When the security light stops turn the ignition cylinder to OFF and then back to the ON position. The security light on the dash will flash for 15 more minutes. After the security light stops flashing for the third time, the new computer has been programmed to the recognize your key again.
Why is antifreeze leaking from underside of engine area on a 2002 Chevy Express van?
Possible leaking hoses or water pump
If the dealer can't order them go to the wrecking yard.
I have now accomplished this repair. To extract the fuse/relay block from the LH front corner of the engine compartment, the master cylinder has to be moved aside. Its lines do not need to be disconnected. The block is secured by one screw at its front right corner. To get to this screw a universal 10mm socket is useful so that the washer bottle does not have to be moved aside. The block is unhooked from its retainer at its left rear corner. Lift the block up and to the right (of the vehicle). The lower cover of the fuse/relay block is released by pushing a small screwdriver into the slots on each side of the block. It is worked loose from the looms on its right side. The overheated socket has to be released. There is a pronged white plastic retainer that is slid to the right (of the vehicle) just enough to release the affected socket. Pull the socket out of the bottom of the block as much as the wire will allow. Unfold the twin lock from the wire insulation and bend the sharply wire back and forth until the socket breaks off the end of the wire. This minimizes the loss of wire length. Lightly scrape tarnish from the wire strands and crimp the new socket onto the wire with a twin lock crimping tool. Reinsert the socket up into the block and push the retainer back into place, making sure all sockets are properly located and retained. The socket I used was slightly different from the original. It has a spring retainer that is not used in this application. This retainer was bent in so that it did not function. The necessary tangs on the socket for the retainer are present. "Reassemble in reverse order of disassembly." The bottom cover of the fuse/relay block is a little hard to get in place but be careful and it will go.
Chevy Express 2000 crank but doesn't start when its raining?
Remove and dry inside rotor cap with hair dryer, look for crack on cap and most likely it does not have seal.
Try applying small amount of silicone to stop moisture in future.
Since there is very little detail given about the problem I can only give a generic answer. If your speedometer has also been "erratic" during high humidity and rainy days, the problem is most likely a cracked case on the ECM. If you silicone the case before the damage to electronics is done, you may salvage the module. Once the module deteriorates, starting becomes harder and harder during wet weather and eventually will not start at all. This problem has been seen on many vehicles andthe most likely reason for your symptom.
You must leave the key in the ignition on the "run position" for 15 minites until the theft light stops flashing then you are able to start the car (if you try to start the car before that you will have to start the time and process over again). If you have a aftermarket alarm in the vehicle you must disable the stock alarm through your dealer. if that is not the situation i would check the starter, wireing on the starter and or battery.
What is the weight of a 2005 Chevrolet Express?
Try looking at the drivers side door either on door side or on the drivers side frame. There should be a white sticker that states the total gvw- it will list total then weight as related to front wheel and rear wheels in metric and lbs. Also this will tell you the size tires recommended and air pressure required.
How do your remove a double action hinge door?
unscrew the plate at the bottom and slide lower end along the floor until the pin at the top can be clear of the indent at the top of the door. Now the door should be clear and unattached!
How do you make my Chevy express stop beeping?
The easiest and quickest way to stop your Chevrolet Express from beeping is to disconnect the power cable from the battery. Wait one minute and replace the cable. The beeping should start again.
How do you remove the rear door panels on a 2002 Chevy Express?
I had the same problem with my 2001 Chevy Express Van. To access the door mechanism you have to pull off the rear panel. The panel on my car had a number of plastic hooks. I pulled from the bottom of the accessible corner of the panel with force in both an outward and upward direction. It wasn't easy but it came off with no damage. To open the door, I reached in and first pulled down to unlatch the top. While holding the door off of the top latch, i pulled up on the bottom to finally pop it open.
Good luck!
How do you remove the stereo from a 2007 Chevrolet express van?
Leave the vehicle parked in a bad neighborhood with the doors unlocked.
How do you change the rear turn signal bulbs on a 2009 Chevy 2500 cargo van?
Chevrolet Express 2500 back or rear turn signal light bulb lamp replacement procedure: Purchase the correct replacement turn signal light bulb(s) first, before disassembling the vehicle. See sources and related links below for replacement bulb information. Then consult your owner's manual for the turn signal light bulb lamp replacement procedure. As simple as it sounds, the owner's manual is the best place to start for bulb replacement instructions and illustrations. You may want to consider replacing both left and right at the same time in order to keep brightness and color equal (optional).
How do replace turn signal bulb on 2004 Chevy Express?
Slide under bumper, you'll see the wire harness, disconnect wire harness / bulb housing from the signal glass housing with a 1/4 counter clockwise turn, replace bulb ( 3157 i believe ) re-install
Where is the interior lamp control module on a 98 Chevy Express van?
It is behind the passenger foot molding, just in front of the door. It pulls off.
it is a 2x2 black box with a terminal of about 7 wires or so
Where is low pressure ac access fitting for 2002 Chevy pickup?
The LOW pressure fitting is SMALLER than the HIGH pressure fitting.
What is the maximum towing capacity of the 2014 Chevrolet Express?
The maximum tosing capacity of the 2014 Chevrolet Express is 6200 lbs..
