0
Volvo 240
Introduced in 1974 along with the 260 series, the Volvo 240 was a mid-size executive car manufactured by Volvo. This model was manufactured in six variations, namely 242DL, 242L, 244GL, 244DL, 245DL and 245L.
653 Questions
Where is the fuel pump relay located on a 1987 Volvo 240 gl how do you tell if it is bad?
I'm not certain where it is in your year... but in my 1991 240 dl sedan it's under the glove box side of the dash... (in an 87 240 DL it's under the kickboard, left of the brake)
I had a terrible time every summer before I figured it out.. car would just crank and not run.. sometimes even in wet damp weather or humid weather.
Finally on the net I read on the "Brickboard" that a guy had the same trouble with 6 volvo's he rebuilt and never was it the computer...
You can tell if the relay is bad if you don't hear that 2 second humm when you turn the ignition key to the on position... if you don't hear it the contacts are stuck in the wrong position or burnt. I hit the relay with my knuckle and in my case it worked again until I could replace it ( a couple of days later.)
there is also a way to over ride the relay by using a jumper relay to get the fuel pump to run without it but putting the jumper in the correct holes of the relay.. which I don't know... but!!!! it will make the fuel pump run continuously..even when you turn the car off.. so don't do this unless you know you'll have to disconnect it when you stop.
If you don't get the Humm with the key in the on position I bet the relay is BAD. You can order one online from a place like "Thepartsbin.com" or other place... about 40 bucks these days.
Hope this info helps.
How do you change the headlight bulb in the 1990 Volvo 240?
1.) Open the hood 2.) Look directly behind the headlight housing inside of the engine compartment
3.) There should be a black plug plugged into the back of the headlight. The back of the headlight should be a grey cone shaped object and should NOT come out i this process.
4.) There is a black ring around the plug which secures the plug onto the headlight housing, turn it counter clockwise to loosen it until it slides back behind the plug.
5.) Pull out the plug and the bulb should be attached to it. you should be able to pop it right out and put in a new one.
*NOTE: this might require a little coercion as 20 year old plastic parts tend to be a bit difficult. Volvo used pretty quality plastic parts on the 240 so you shouldn't worry too much about breaking anything but you should be careful as parts can be hard to find. Hope this helps, i own an 89' 240 dl sedan so it should be the same as yours.
Where is the fuse box 1988 volvo 240?
In North America- lower left side in the drivers compartment. near your left leg. behind a plastic panel. there's a knob at the bottom- turn to open.
Opposite side in Australia, UK, etc.
What is the towing capacity of a 1990 Volvo 240?
My manual says 3500lbs with a 300lb tongue weight. I personally wouldn't tow anything over 2500 lbs with a 240.
How do you remove 1986 240 starter?
You have to lift the car and look from underneath. There are 2 bolts that go thru the bellhousing and connect to the starter. Locate the starter (on Left Hand drive the starter is on the driver side). The 2 bolts are 19mm. The bottom bolt is easier to get out, the top one will require a long extension on the racthet and perhaps an impact gun. Try to loosen with a breaker bar if you have one.
What could be keeping a 1990 Volvo 240 series from going into overdrive?
Overdrive relay switch behind the middle air vents..... Manual Transmission: the wires sometimes break if it is the type with the button on the gear/knob/ stick........... if it is a manual transmission.......the switch on the gearbox which tells when 4th gear is engaged can be faulty.....and will not allow the overdrive to engaged.
How do you set the timing on a 87 Volvo 240 with a b230 engine?
Loosen the Tensioner pulley and push against the spring, and put a nail in the small hole to lock the spring back. Align the Crank pulley, Intermediate shaft, and Cam pulley to TDC, look for the notches for reference. Then put the belt on the gears in that order, and re check. Then pull the nail, and lock the bearing in place to keep correct tension.
How do you fix a front cam seal and front crank seal on 1988 Volvo 240dl wagon engine?
Check your flame trap first for a clogged trap.
How do you remove the Volvo 240 front headrest?
On the backside in the middle of the seats there is two buttons you have to push and then pull up the headrest.
//Sam
How do you change the gear shifter on a Volvo 240 gl where do you unscrew it?
The gear shifter has a retaining clip, just below the shifter knob. Hold the retaining clip in, on both sides of the shifter rod, and the shifter knob will come off.
Where is the amplifier in Volvo 240?
under the dash on the passengers side and below the glove-box..attached to the firewall
You might need to replace the fuel pump relay, as it tends to burn out in the 200 series. You might need to replace the fuel pump relay, as it tends to burn out in the 200 series.
Do you take a solar cover off in the event of rain?
The only reasons to take a solar cover off should be to swim or if the water temperature gets hotter than you desire.
Typically the problem lies with the rheostat, the knob you turn to make the dash lights brighter or dimmer. When you turn the knob a little metal finger rubs along a circular spring changing the resistance, thus changing the intensity of illumination. That spring gets corroded. You can clean it, or you can replace it.
How you change in dash bulbs for Volvo 2000 s40?
Undo the 2 screws on the plastic cover around the dash. Remove it and you will see 3 more screws. Pull the clocks to the side and you will see the all the little bulbs.
i just changed the starter yesterday, youl need a 90 degree pivit adapter plus a3/4 inch shallow socket plus 10-14 inches of extension and possibly abreaker bar on ratchet handle. good luck spray w-d40 first Ike
How do you check the transmission fluid in a 2002 Volvo V70?
Sealed transmission. That is why there is no dip stick for checking level. You can also see it is not in the owners manual. No dipstick. Its a sealed unit...
How do you adjust the idle on a Volvo?
I'm not sure what year or model of the car but if its somewhat new meaning about 1994. Then the computer does it and there is no adjustment. If you getting a rough or low idle it is probably time for a tune-up. If tune-up doesn't work you may have to replace idle control valve, up to 1989 there was an idle adjustment knob on throtle body for fine tunning.
How do you replace the gear selector lamp on a Volvo 940?
unscrew the two hex scres in the middle of the consoule take off the ashtray and cover for the fuses there will be a clip get a small screwdriver to pry the clip off and then you can remvoe the panle and there will be a small bulb that you can replace under the shifter
How do you replace headlight lens cover for Volvo 240 1993?
Unless it is broken or cracked it does not need to be replaced. At Walmart and I'm sure automotive stores there is a product ($20) that restores the lens. It comes in a package...includes two grades of sandpaper, a gritty compound and a sealer. It is amazing. Used it on my son's 1992 Subaru and my daughters 1989 Volvo. They are almost new and you can actually see at night now.
How do you set the clock on a Volvo s40?
Press and hold the rotary button on the clock face, then turn and hold in the direction you wish to go, let go when it gets near correct time then repeat using small increments.
