0
Chevy G20
Manufactured by the American automaker General Motors Company for the G-Series product line, the Chevy G20 was a passenger van powered by a 4.3 liter V6 engine, which can generate up to 165 horsepower.
1,037 Questions
How to remove engine cover on G20 van?
Starting at the base, remove two bolts through the floor; unhook the clamps under the dash. Removing the passenger side seat will be very helpful. Check carefully for radio connections especially in conversion/aftermarket applications. Then slowly tilt the "doghouse" up while pulling backwards. If not moving look for more hidden bolt/screws.
What fuse on a 1979 Chevy van a great laker causes the headlights to turn on?
usually the headlights have a fusible link near the battery but check for power to the highbeam switch and headlight switch first.
How do you remove the seats from a 97 Chevy 1500 Express Van?
Look under the benchs, on the inside of the leg, there should be a cut out in the flooring in the back. Lift it up the flooring and underneath is the pin with an orange handle that holds the benches in place. Rotate the pin so the handle is vertical and wiggle it out. Once both pins are removed. Disconnect the seat belts from the benches, slide the bench back a couple of inches, and lift the bench out.
How do you take off a u-joint on a 1989 Chevrolet G20 van and is it pressed on?
Hey, I just changed mine. You can get a kit do do it. Or you get a nice size c- clamp, a deep well socket that is bigger than the u joint cap on one side and a deep well socket that is a little smaller than the cap on the other side. Use the c-clamp to press the one side into the other (larger) socket. Once pressed all the way through, you should be able to slip it out.
I had a 1989 S-10 that would do that when the computer became hot.
I have a 1992 Silverado K1500 350 with the same exact symptoms. Replaced the ignition control module and fixed it! Apparently, it gets hot and quits, then it works again when it cools down, so replace it.
How do you tune the carburetor of an '87 Virago?
throw them away, get single carb manifold from ccworks.com, put on kiehin harley carb. all other fixes are difficult to do . hitachis especially are a bear to get right. mikunis not so bad.
Where is fuel pump relay on 1995 Chevy G20 van?
On my "96" 1500 Pk-up. Its under the hood, on the diver's side, in the fuse box.
How can you deactivate the ABS on your 1999 Chevy Astro Van Can you do it by pulling a fuse?
pull mthe fuse under the hood a 60 amp fuse it worked for me.
Is there a relay for the AC compressor clutch and where is it on a 1994 Chevy G20?
You should be able to find a shop manual at your local library with diagnostics and specs -- make copies of the right sections as they are usually only available in the REFERENCE section...good luck :) I guess I will answer my own question... (service manual was "in the mail" when I had asked it). There is not a relay for the clutch, it's wired directly from the pressure switches.
Where is oil filter on a 350 small block?
Drivers side, back of motor, all the at the bottom. You should be able to see it from up top, with the hood open, however, to change it, you will need to get under it.
How can i open the hood on a focus?
That was tricky, you have to open the hood from front using your keys. Go to the front of the car, rotate the "FORD" label (located at the middle) upward. Behind it, there you can insert the key and tilt it to the left, then to the right, and the hood will pop up! That was a discovery! CHeers
How do you replace fuel pump on Chevy van C20?
Take the tank down the pump is placed inside the tank on the top of the tank
How do you know if a thermostat is bad in a 1994 astro van?
Faulty thermostats can manifest themselvs in several ways. Some stick open, some stick closed and some stick in one position for a while then suddenly open or close. The ones that stick open will never allow the engine to completely warm up and you will get cold or cool air coming from the heater. The ones that stick closed will cause the engine to warm normally but then the temprature continues to climb and you can loose coolant and possibly harm the engine. The ones that stick for a while are interesting because the vehicle will run cold then turn warm quite rapidly or more likely the thermostat will stick closed and not open until the vehicle is quite warm and possibly you have started to loose coolant. In any case, the easiest way to detect a bad thermostat is to replace it. If the problem goes away, it was the thermostat. If you REALLY need to know if the thermostat is bad, remove it from the vehicle, put it in a pan of water and bring the water to a boil on the stove. Watch the thermostat. If it opens smoothly when the water gets to the designated temprature then the thermostat is ok. If the thermostat opens suddenly, fails to open or is open when you remove it from the vehicle, the thermostat has failed.
How do you remove a heater core from a 95 Chevy G20 5.7L with air?
You have a 3rd generation Chevy van. You have to remove the instrument panel cover and instrument cluster. Be sure to disconnect ALL wiring harnesses. Remove lower panel below the steering column, disconnect wiring harness on headlight switch. Also, you need to remove the bolts holding in your air conditiong/heater control. Remove the bolts holding up the steering column. Remove center console, which is over the engine cover. Pull out the radio and disconnect harness and antenna lead. NOTE: if radio wont come out, remove engine cover (dog house). Now the fun part... Remove the dash, that way you can get to the "2" straps holding the heater core. Don't forget to remove the heater hoses first.
How do i fix the air conditioning in a 1995 g20 cargo van?
First check charge with a guage at ports high/low side lines, that is if you hear clutch go off and on so you know compressor is working
Where is the blower motor located on a 2001 Chevy Astro Vans?
It is located in the engine compartment on the passenger side of the vehicle just behind and to the left of the radiator overflow tank and windshield washer resovoir.
How do you change the top right freeze plug on a 1998 Monte Carlo 3.1?
Take a screwdriver and gently pry out the plug without damaging the hole. Set the new plug in place and tap it in by going round the edge with a hammer.
Is fuelpump in the gas tank on a 1989 Chevy conversion van?
Yes it is. There is a fuse for it under the hood.
check the ignition coil
Where is the neutral safety switch located on a 94 Chevy lunina euro?
It is on the side of the transmission were the shifter cable hooks to the trans.
Can you remove an high top off an 1995 Chevy van?
No. They cut out the original roof, and place the fiberglass in place over the hole. You could remove if you welded on a new roof panel.
